
浏览全部资源
扫码关注微信
1.辽宁石油化工大学石油天然气工程学院 抚顺 113001
2. 中国石油集团工程有限公司北京项目管理公司 北京 102206
3. 辽宁石油化工大学环境与安全工程学院 抚顺 113001
4. 抚顺市特种设备监督检验所 抚顺 113000
赵艳锋,女,讲师,辽宁石油化工大学环境与安全工程学院,15704234046,E-mail:zhao761806873@foxmail.com。研究方向:LNG冷能利用。
收稿:2025-01-03,
修回:2025-02-12,
录用:2025-04-08,
网络出版:2025-12-22,
移动端阅览
杨婷,寇鹏,赵艳锋等.液化天然气冷能回收利用技术研究进展[J].制冷学报,
Yang Ting,Kou Peng,Zhao Yanfeng,et al.Research Progress of Liquefied Natural Gas Cold Energy Recovery and Utilization Technology[J].Journal of Refrigeration,
杨婷,寇鹏,赵艳锋等.液化天然气冷能回收利用技术研究进展[J].制冷学报, DOI:10.12465/issn.0253-4339.20250103001. CSTR: XXXXX.XX.XXX.20250103001.
Yang Ting,Kou Peng,Zhao Yanfeng,et al.Research Progress of Liquefied Natural Gas Cold Energy Recovery and Utilization Technology[J].Journal of Refrigeration, DOI:10.12465/issn.0253-4339.20250103001. CSTR: XXXXX.XX.XXX.20250103001.
本文阐述了近些年针对LNG(液化天然气,liquefied natural gas)冷能利用的技术研究成果,并指出了这些技术的优缺点、面临的挑战以及实际应用情况。根据应用研究的交叉性、综合性、工程实际性展望未来LNG冷能利用的发展趋势,提出了LNG冷能低温贮藏生物技术,并在目前利用LNG的联产系统基础上展望多联产系统的发展趋势和研究策略,提出了加快搭建工艺实验平台、加强系统多角度性能研究、加强系统安全性评估的必要性。提出并分析了LNG冷能未来可应用的领域和总体研究方向。
This study describes the technical research results on liquefied natural gas (LNG) cold-energy utilization in recent years and highlights the advantages, disadvantages, challenges, and practical applications of these technologies. Based on the intersectionality, comprehensiveness, and practicality of applied research, this study discusses the future development trend of LNG cold-energy utilization, constructively proposes LNG cold-energy cryogenic-storage biotechnology, and suggests the development trend and research strategy of a multi-combined generation system based on the current cogeneration system utilizing LNG. It also emphasizes the necessity of accelerating the establishment of a process experimental platform, thereby strengthening research on system performance from multiple perspectives and enhancing the safety assessment of the system. Finally, future applicable fields and overall research directions for LNG cold energy are proposed and analyzed.
马晓敏 . 《中国天然气发展报告(2024)》发布 [N]. 中国矿业报 , 2024-07-30 (002).
MA Xiaomin . China Natural Gas Development Report 2024released [N]. China Mining News , 2024-07-30 (002).
李峰 . 大型LNG接收站冷能利用技术分析与工程实践 [J]. 化工管理 , 2022 ( 13 ): 149 - 152 .
LI Feng . Technical analysis and engineering practice of cold energy utilization in large LNG receiving terminal [J]. Chemical Management , 2022 ( 13 ): 149 - 152 .
XU Wendong , DUAN Jiao , MAO Wenjun . Process research and analysis on potential development of a novel air separation process cooled by LNG cold energy [J]. Advanced Materials Research , 2013 , 805/806 : 609 - 615 .
HAN Fenghui , WANG Zhe , JIANG Yuemao , et al . Energy assessment and external circulation design for LNG cold energy air separation process under four different pressure matching schemes [J]. Case Studies in Thermal Engineering , 2021 , 27 : 101251 .
HAMAYUN M H , RAMZAN N , HUSSAIN M , et al . Conventional and advanced exergy analyses of an integrated LNG regasification-air separation process [J]. Industrial & Engineering Chemistry Research , 2022 , 61 ( 7 ): 2843 - 2853 .
袁建涛 . 关于降低冷能空分供冷温度的方法研究 [J]. 山东化工 , 2024 , 53 ( 6 ): 195 - 197 .
YUAN Jiantao . Study on the method of reducing the cooling temperature of cold energy air separation [J]. Shandong Chemical Industry , 2024 , 53 ( 6 ): 195 - 197 .
WANG Shuting , HUANG Kun , WANG Xiaoshang , et al . Study and economic evaluation on the process of calorific value adjustment in the LNG receiving terminal [J]. The Open Petroleum Engineering Journal , 2016 , 9 ( 1 ): 226 - 235 .
GAO Ting , LIN Wensheng , GU Anzhong . Improved processes of light hydrocarbon separation from LNG with its cryogenic energy utilized [J]. Energy Conversion and Management , 2011 , 52 ( 6 ): 2401 - 2404 .
ZHANG Ruihang , WU Chufan , SONG Wuwenjie , et al . Energy integration of LNG light hydrocarbon recovery and air separation: Process design and technic-economic analysis [J]. Energy , 2020 , 207 : 118328 .
PAN Jie , LI Mofan , LI Ran , et al . Design and analysis of LNG cold energy cascade utilization system integrating light hydrocarbon separation, organic Rankine cycle and direct cooling [J]. Applied Thermal Engineering , 2022 , 213 : 118672 .
邓志安 , 李莉 , 胡永群 , 等 . LNG轻烃回收工艺的设计与分析 [J]. 低碳化学与化工 , 2023 , 48 ( 4 ): 176 - 182 .
DENG Zhian , LI Li , HU Yongqun , et al . Design and analysis of LNG light hydrocarbon recovery process [J]. Low-Carbon Chemistry and Chemical Engineering , 2023 , 48 ( 4 ): 176 - 182 .
崔国彪 , 刘阳 , 安海燕 , 等 . 利用LNG冷能粉碎废旧橡胶工艺 [J]. 天然气与石油 , 2013 , 31 ( 2 ): 24 - 26, 5 .
CUI Guobiao , LIU Yang , AN Haiyan , et al . Rubber comminution by utilizing LNG cold energy [J]. Natural Gas and Oil , 2013 , 31 ( 2 ): 24 - 26, 5 .
苗沃生 , 李琦芬 , 杨涌文 , 等 . LNG冷能用于橡胶粉碎的流程优化研究 [J]. 天然气化工(C1化学与化工) , 2020 , 45 ( 2 ): 77 - 80, 94 .
MIAO Wosheng , LI Qifen , YANG Yongwen , et al . Process optimization of LNG cold energy use in rubber crushing based on exergy analysis [J]. Natural Gas Chemical Industry , 2020 , 45 ( 2 ): 77 - 80, 94 .
ABBAS-ABADI M S , KUSENBERG M , SHIRAZI H M , et al . Towards full recyclability of end-of-life tires: Challenges and opportunities [J]. Journal of Cleaner Production , 2022 , 374 : 134036 .
LEE D H , PARK S , KIM H T , et al . Proposing a new solution for marine debris by utilizing on-board low-temperature eco-friendly pulverization system [J]. Scientific Reports , 2021 , 11 : 24364 .
XIN Yue , ZHANG Yindi , XUE Peng , et al . The optimization and thermodynamic and economic estimation analysis for CO 2 compression-liquefaction process of CCUS system using LNG cold energy [J]. Energy , 2021 , 236 : 121376 .
秦锋 , 陈海平 , 明红芳 , 等 . 基于LNG冷能的膜-深冷分离碳捕集耦合系统工艺模拟与分析 [J]. 低碳化学与化工 , 2024 , 49 ( 2 ): 96 - 104 .
QIN Feng , CHEN Haiping , MING Hongfang , et al . Process simulation and analysis of membrane-cryogenic separation carbon capture coupling system based on LNG cool energy [J]. Low-Carbon Chemistry and Chemical Engineering , 2024 , 49 ( 2 ): 96 - 104 .
张玉健 , 顾丛汇 , 姚寿广 . 某渔船燃料LNG冷能利用方案的设计和优化 [J]. 船舶工程 , 2022 , 44 ( 1 ): 1 - 7, 40 .
ZHANG Yujian , GU Conghui , YAO Shouguang . Design and optimization of cold energy utilization scheme for a LNG fuel-powered fishing boat [J]. Ship Engineering , 2022 , 44 ( 1 ): 1 - 7, 40 .
NAJIM A . A review of advances in freeze desalination and future prospects [J]. NPJ Clean Water , 2022 , 5 : 15 .
谢春刚 , 孙靖 . 基于LNG冷能的海水冷冻淡化机理研究 [J]. 低温与超导 , 2012 , 40 ( 2 ): 11 - 15 .
XIE Chungang , SUN Jing . Mechanism research on seawater freezing desalination using cold energy of LNG [J]. Cryogenics & Superconductivity , 2012 , 40 ( 2 ): 11 - 15 .
曹文胜 , 徐建壮 , 郭兆春 , 等 . 冷能利用片冰机海水淡化动态仿真 [J]. 化工进展 , 2021 , 40 ( 增刊1 ): 61 - 68 .
CAO Wensheng , XU Jianzhuang , GUO Zhaochun , et al . Dynamic simulation of cold energy desalination using ice-sheet machine [J]. Chemical Industry and Engineering Progress , 2021 , 40 ( Suppl.1 ): 61 - 68 .
苗旺 , 鲍军江 , 张宁 , 等 . 利用LNG冷能水合物海水淡化–冷电联产系统 [J]. 工程热物理学报 , 2023 , 44 ( 6 ): 1452 - 1458 .
MIAO Wang , BAO Junjiang , ZHANG Ning , et al . A combined system of hydrate seawater desalination, cooling and power generation using LNG cold energy [J]. Journal of Engineering Thermophysics , 2023 , 44 ( 6 ): 1452 - 1458 .
SERMSUK M , SUKJAI Y , WIBOONRAT M , et al . Utilising cold energy from liquefied natural gas (LNG) to reduce the electricity cost of data centres [J]. Energies , 2021 , 14 ( 19 ): 6269 .
TIAN Zhen , QI Zhixin , GAN Wanlong , et al . A novel negative carbon-emission, cooling, and power generation system based on combined LNG regasification and waste heat recovery: Energy, exergy, economic, environmental (4E) evaluations [J]. Energy , 2022 , 257 : 124528 .
王瑜 , 吴露露 , 康娜 , 等 . 数据中心喷雾冷却系统研究进展和要素分析 [J]. 科学技术与工程 , 2021 , 21 ( 18 ): 7391 - 7403 .
WANG Yu , WU Lulu , KANG Na , et al . Research progress and factors analysis of spray cooling system in data center [J]. Science Technology and Engineering , 2021 , 21 ( 18 ): 7391 - 7403 .
刘梅梅 , 赵金文 , 刘鑫 , 等 . LNG卫星站冷能与低温太阳能联合发电循环 [J]. 石油与天然气化工 , 2021 , 50 ( 3 ): 40 - 48 .
LIU Meimei , ZHAO Jinwen , LIU Xin , et al . Combined power generation cycle of cold energy and low-temperature solar energy in LNG satellite station [J]. Chemical Engineering of Oil & Gas , 2021 , 50 ( 3 ): 40 - 48 .
蔡东旭 , 王荧光 , 刘豪爽 , 等 . 改进型三级串联多股流LNG冷能发电系统性能研究 [J]. 低碳化学与化工 , 2024 , 49 ( 11 ): 122 - 132 .
CAI Dongxu , WANG Yingguang , LIU Haoshuang , et al . Research on the performance of improved three-stage series multi-stream LNG cold energy power generation system [J]. Low Carbon Chemistry and Chemical Engineering , 2024 , 49 ( 11 ): 122 - 132 .
SUN Wenyi , LI Ming , PAN Zhen , et al . A heat source self-supplied thermodynamic system using liquefied natural gas: Performance evaluation and three-objective optimization [J]. Journal of Cleaner Production , 2023 , 429 : 139545 .
张丽 , 马贵阳 , 潘振 , 等 . 基于SAGD稠油开采余热利用的冷热电三联供系统 [J]. 工程热物理学报 , 2018 , 39 ( 9 ): 1890 - 1898 .
ZHANG Li , MA Guiyang , PAN Zhen , et al . Thermodynamic analysis of combined cooling heating and power(CCHP)system based on waste heat recovery in heavy oil extraction with steam assisted gravity drainage(SAGD) process [J]. Journal of Engineering Thermophysics , 2018 , 39 ( 9 ): 1890 - 1898 .
CHA S H , NA S I , LEE Y H , et al . Thermodynamic analysis of a gas turbine inlet air cooling and recovering system in gas turbine and CO 2 combined cycle using cold energy from LNG terminal [J]. Energy Conversion and Management , 2021 , 230 : 113802 .
ENTEZARI A , BAHARI M , ASLANI A , et al . Systematic analysis and multi-objective optimization of integrated power generation cycle for a thermal power plant using Genetic algorithm [J]. Energy Conversion and Management , 2021 , 241 : 114309 .
KAVIANI B , KULUS D . Cryopreservation of endangered ornamental plants and fruit crops from tropical and subtropical regions [J]. Biology , 2022 , 11 ( 6 ): 847 .
BELLAS J , PAREDES E . Advances in the cryopreservation of sea-urchin embryos: Potential application in marine water quality assessment [J]. Cryobiology , 2011 , 62 ( 3 ): 174 - 180 .
潘本艺 , 杨帆 , 周莉 , 等 . 液化天然气冷能利用的联合动力循环 [J]. 高校化学工程学报 , 2021 , 35 ( 4 ): 702 - 710 .
PAN Benyi , YANG Fan , ZHOU Li , et al . Combined power cycle for cold energy utilization of liquefied natural gas [J]. Journal of Chemical Engineering of Chinese Universities , 2021 , 35 ( 4 ): 702 - 710 .
郭媛媛 , 魏鹤鸣 , 潘振 , 等 . 基于LNG冷能的联合循环系统多目标性能 [J]. 高校化学工程学报 , 2022 , 36 ( 6 ): 870 - 878 .
GUO Yuanyuan , WEI Heming , PAN Zhen , et al . Multi-objective performance of combined cycle systems using LNG cold energy [J]. Journal of Chemical Engineering of Chinese Universities , 2022 , 36 ( 6 ): 870 - 878 .
KONUR O , COLPAN C O , SAATCIOGLU O Y . A comprehensive review on organic Rankine cycle systems used as waste heat recovery technologies for marine applications [J]. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects , 2022 , 44 ( 2 ): 4083 - 4122 .
朱柏彤 , 李彦军 , 张强 , 等 . 双燃料船舶主机余热及LNG冷能利用分析 [J]. 工程热物理学报 , 2022 , 43 ( 11 ): 2893 - 2903 .
ZHU Baitong , LI Yanjun , ZHANG Qiang , et al . Analysis of waste heat and LNG cold energy utilization of main engine of dual fuel ship [J]. Journal of Engineering Thermophysics , 2022 , 43 ( 11 ): 2893 - 2903 .
夏睿 , 王哲 , 董博 , 等 . FLNG船舶能量管理系统设计与性能优化 [J]. 中国电机工程学报 , 2024 , 44 ( 8 ): 3165 - 3177 .
XIA Rui , WANG Zhe , DONG Bo , et al . Design and performance optimization of energy management system for FLNG ships [J]. Proceedings of the CSEE , 2024 , 44 ( 8 ): 3165 - 3177 .
BAO Junjiang , HE Xiang , DENG Yuanyuan , et al . Parametric analysis and multi-objective optimization of a new combined system of liquid carbon dioxide energy storage and liquid natural gas cold energy power generation [J]. Journal of Cleaner Production , 2022 , 363 : 132591 .
PARK J , CHO S , QI Meng , et al . Liquid air energy storage coupled with liquefied natural gas cold energy: Focus on efficiency, energy capacity, and flexibility [J]. Energy , 2021 , 216 : 119308 .
TAN Hongbo , LI Yanzhong , TUO Hanfei , et al . Experimental study on liquid/solid phase change for cold energy storage of Liquefied Natural Gas (LNG) refrigerated vehicle [J]. Energy , 2010 , 35 ( 5 ): 1927 - 1935 .
卢昕悦 , 陈锐莹 , 姜夏雪 , 等 . 耦合LNG冷能的液态空气储能系统和液态CO 2 储能系统对比分析 [J]. 化工学报 , 2024 , 75 ( 9 ): 3297 - 3309 .
LU Xinyue , CHEN Ruiying , JIANG Xiaxue , et al . Comparative study on liquid air energy storage system and liquid carbon dioxide energy storage system coupled with liquefied natural gas cold energy [J]. Journal of Chemical Engineering , 2024 , 75 ( 9 ): 3297 - 3309 .
苏要港 , 吴晓南 , 廖柏睿 , 等 . 耦合LNG冷能及ORC的新型液化空气储能系统分析 [J]. 储能科学与技术 , 2022 , 11 ( 6 ): 1996 - 2006 .
SU Yaogang , WU Xiaonan , LIAO Borui , et al . Analysis of novel liquefied-air energy-storage system coupled with LNG cold energy and ORC [J]. Energy Storage Science and Technology , 2022 , 11 ( 6 ): 1996 - 2006 .
LUKETA-HANLIN A . A review of large-scale LNG spills: experiments and modeling [J]. Journal of Hazardous Materials , 2006 , 132 ( 2/3 ): 119 - 140 .
HUANG Bin , LI Jiaoyang , FU Cheng , et al . A comprehensive review of stratification and rollover behavior of liquefied natural gas in storage tanks [J]. Processes , 2022 , 10 ( 7 ): 1360 .
VÍLCHEZ J A , VILLAFAÑE D , CASAL J . A dispersion safety factor for LNG vapor clouds [J]. Journal of Hazardous Materials , 2013 , 246 : 181 - 188 .
ATIENZA-MÁRQUEZ A , BRUNO J C , AKISAWA A , et al . Fluids selection and performance analysis of a polygeneration plant with exergy recovery from LNG-regasification [J]. Energy , 2019 , 176 : 1020 - 1036 .
0
浏览量
0
下载量
0
CSCD
关联资源
相关文章
相关作者
相关机构
京公网安备11010802024621