油循环率对电动汽车空调压缩机性能的影响

陶宏; 张婷; 吴生礼; 程英男; 缪剑; 邵昕宏

doi:10.3969/j.issn.0253-4339.2021.06.140

您当前的位置：

首页 >

文章列表页 >

油循环率对电动汽车空调压缩机性能的影响

更新时间：2024-07-18

- 油循环率对电动汽车空调压缩机性能的影响
- Effect of Oil Circulation Rate on the Performance of Compressor in Electric Vehicle Air-conditioning
- 制冷学报 2021年42卷第6期
- 作者机构：
  
  上海海立新能源技术有限公司
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2021.06.140
  中图分类号：
- 纸质出版日期：2021，
- 稿件说明：
移动端阅览
陶宏, 张婷, 吴生礼, 等. 油循环率对电动汽车空调压缩机性能的影响[J]. 制冷学报, 2021,42(6).

TAO HONG, ZHANG TING, WU SHENGLI, et al. Effect of Oil Circulation Rate on the Performance of Compressor in Electric Vehicle Air-conditioning. [J]. Journal of refrigeration, 2021, 42(6).
陶宏, 张婷, 吴生礼, 等. 油循环率对电动汽车空调压缩机性能的影响[J]. 制冷学报, 2021,42(6). DOI： 10.3969/j.issn.0253-4339.2021.06.140.

TAO HONG, ZHANG TING, WU SHENGLI, et al. Effect of Oil Circulation Rate on the Performance of Compressor in Electric Vehicle Air-conditioning. [J]. Journal of refrigeration, 2021, 42(6). DOI： 10.3969/j.issn.0253-4339.2021.06.140.

摘要

为研究油循环率对电动汽车用变频空调涡旋式压缩机（R134a）性能的影响，本文通过应用第二制冷剂法压缩机性能测试台及油分离式油循环率测量装置，实验对比了压缩机转速分别为3 000、4 500、6 000 r/min在两个高负荷工况下的性能，实验结果表明：油循环率对电动汽车空调涡旋式压缩机性能有显著影响。油循环率在1%~10%范围内，同一工况、不同转速时，压缩机容积效率和电效率均随油循环率降低而减小0.02~0.05，而压缩机排气温度和壳体温度均随油循环率的降低而升高5~15 ℃，且低转速时油循环率的影响更大；总体而言，油循环率<5%时，油循环率对压缩机性能的影响比油循环率>5%时更显著，因此5%是适度的油循环率。

Abstract

To investigate the effect of the oil circulation rate (OCR) on the performance of a variable-speed scroll compressor (R134a) for electric vehicle air-conditioning

elaborate experiments were conducted to obtain the performance and OCR in a test bench using a secondary fluid calorimeter and OCR measurement by a separator. The results show that the OCR significantly influences the scroll compressor performance when speeds of 3 000 r/min

4 500 r/min

and 6 000 r/min are compared under two heavy-load conditions. More specifically

when the OCR is between 1% and 10% under the same condition

the volume efficiency and electrical efficiency decline by 0.02–0.05

whereas both the discharge temperature and shell temperature rise by 5–15 K as the OCR decreases from 10% to 1%. This occurs at every speed

and it is especially evident at low speed. Generally

a moderate OCR should be near 5% because an OCR that is less than 5% has a higher impact than that greater than 5%.

关键词

油循环率变频压缩机电动汽车空调

Keywords

oil circulation ratevariable speed compressorelectric vehicleair-conditioning

references

浏览量

1198

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

油循环率对电动汽车CO2热泵系统性能的影响

三维变形管能量回收器在夏季空调新风系统中的应用

电动车跨临界CO₂热系统充注定量需求规律及非适充系统失稳特性

电动汽车热泵空调系统冬季运行策略研究

降压装置对电动车动力电池制冷剂直接冷却系统的影响