带有分凝器的小型自复叠制冷循环性能分析

张丽; 徐士鸣; 都萍; 杨春光; 高红岩; 舒卫华

doi:10.3969/j.issn.0253-4339.2015.04.052

您当前的位置：

首页 >

文章列表页 >

带有分凝器的小型自复叠制冷循环性能分析

更新时间：2024-07-18

- 带有分凝器的小型自复叠制冷循环性能分析
- Performance of a Small-sized Auto-cascade Refrigerator with a Fractionation Heat Exchanger
- 制冷学报 2015年36卷第4期
- 作者机构：
  
  1. 大连理工大学能源与动力工程学院
  2. 大连海洋大学机械与动力工程学院
  3. 松下冷链（大连）有限公司营业技术部
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2015.04.052
  中图分类号：
- 纸质出版日期：2015
- 稿件说明：
移动端阅览
张丽, 徐士鸣, 都萍, 等. 带有分凝器的小型自复叠制冷循环性能分析[J]. 制冷学报, 2015,36(4).

Zhang Li, Xu Shiming, Du Ping, et al. Performance of a Small-sized Auto-cascade Refrigerator with a Fractionation Heat Exchanger[J]. Journal of refrigeration, 2015, 36(4).
张丽, 徐士鸣, 都萍, 等. 带有分凝器的小型自复叠制冷循环性能分析[J]. 制冷学报, 2015,36(4). DOI： 10.3969/j.issn.0253-4339.2015.04.052.

Zhang Li, Xu Shiming, Du Ping, et al. Performance of a Small-sized Auto-cascade Refrigerator with a Fractionation Heat Exchanger[J]. Journal of refrigeration, 2015, 36(4). DOI： 10.3969/j.issn.0253-4339.2015.04.052.

摘要

为了提高小型自复叠制冷装置中CO2和丙烷的分离效率，在循环中增设了分凝器。分析了CO2浓度、冷凝器出口蒸汽干度及分凝器高压侧出口温度对带有分凝器的自复叠制冷循环性能的影响。结果表明，当CO2质量浓度从0.22上升到0.31时，实验和理论计算的蒸发温度分别升高了6.8 K和5.7 K，相应的COP分别提高了68.3%和24.9%。当冷凝器出口蒸汽干度从0.5增加到0.9时，蒸发温度先降低后升高，在干度等于0.7时达到了211.37 K的最低值；COP陡降了98.8%。此外，分凝器高压侧出口温度升高8.21 K导致蒸发温度升高了1.41 K，COP增加了21.3%。

Abstract

A fractionation heat exchanger was employed to improve the separation efficiency of CO2 and propane in the small-sized auto-cascade refrigeration cycle. The effects of CO2 mass concentration

vapor quality at condenser outlet and the outlet temperature on the high-pressure side of the fractionation heat exchanger were analyzed. Results show that as CO2 mass concentration grows from 0.22 to 0.31

the evaporating temperatures of the experiment and theoretical calculation are raised by 6.8 K and 5.7 K

respectively. And the corresponding COP is increased by 68.3% and 24.9%

respectively. Simulation data also reveal that as the vapor quality increases from 0.5 to 0.9

the evaporating temperature reaches the minimum of 211.37 K and COP drops sharply by 98.8% at a vapor quality of 0.7. In addition

when the outlet temperature on the high-pressure side of the fractionation heat exchanger is raised by 8.21 K

the evaporating temperature and COP are increased by 1.41 K and 21.3%

respectively.

关键词

Keywords

references

浏览量

2758

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

二氧化碳喷射器运行效率的实验研究

CO2应用于我国工商制冷行业的适用性研究

出口过热度对CO2微通道蒸发器性能的影响

基于套管换热器优化的CO2跨临界热泵高温供热性能提升研究

基于R1234yf/R116/R14混合工质三级自复叠制冷系统性能模拟