冰浆在水平圆管过渡区内流动特性的影响因素

郝达云; 王悦; 王晓春

doi:10.12465/j.issn.0253-4339.2025.04.106

您当前的位置：

首页 >

文章列表页 >

冰浆在水平圆管过渡区内流动特性的影响因素

更新时间：2025-08-28

- 冰浆在水平圆管过渡区内流动特性的影响因素
- Influencing Factors of Flow Characteristics of Ice Slurry in the Flow Transition Zone of Horizontal Circular Tubes
- 制冷学报 2025年46卷第4期页码：106-113
- 作者机构：
  
  1.苏州科技大学环境科学与工程学院　苏州　215009
  2.苏州科技大学天平学院　苏州　215009
- 作者简介：
  
  王晓春，男，博士，苏州科技大学环境科学与工程学院，18505127962，E-mail：sprdawn@163.com。研究方向：冰浆流动特性。
- 基金信息：
- DOI：10.12465/j.issn.0253-4339.2025.04.106
  中图分类号： TB61⁺1;TB657.5
- 收稿日期：2024-03-12，
  
  修回日期：2024-06-12，
  
  录用日期：2024-07-18，
  
  纸质出版日期：2025-08-16
- 稿件说明：
移动端阅览
郝达云, 王悦, 王晓春. 冰浆在水平圆管过渡区内流动特性的影响因素[J]. 制冷学报, 2025,46(4):106-113.

Hao Dayun, Wang Yue, Wang Xiaochun. Influencing Factors of Flow Characteristics of Ice Slurry in the Flow Transition Zone of Horizontal Circular Tubes[J]. Journal of refrigeration, 2025, 46(4): 106-113.
郝达云, 王悦, 王晓春. 冰浆在水平圆管过渡区内流动特性的影响因素[J]. 制冷学报, 2025,46(4):106-113. DOI： 10.12465/j.issn.0253-4339.2025.04.106.

Hao Dayun, Wang Yue, Wang Xiaochun. Influencing Factors of Flow Characteristics of Ice Slurry in the Flow Transition Zone of Horizontal Circular Tubes[J]. Journal of refrigeration, 2025, 46(4): 106-113. DOI： 10.12465/j.issn.0253-4339.2025.04.106.

摘要

冰浆等含有大量悬浮颗粒的固-液两相浆体，在管道内的流动形态决定了其阻力特性。为确保浆体输运系统的安全、节能运行并预防堵塞，通过实验研究了浆体在管道内的流动特性及其临界雷诺数（

）。重点分析了过渡区内浆体的流动形态、固相含量、颗粒粒径和管径对浆体流动特性的影响。结果表明：固相含量的增加会使

增大，而管径和粒径的增加会导致

的降低；浆体的流态转变发生在雷诺数

为1 700~2 600；当在过渡区间，浆体的阻力系数随

的增加呈先增大后减小的趋势。

Abstract

Slurries containing a large number of suspended particles

such as ice slurries

have a strong correlation between internal flow patterns and resistance characteristics. The study of its flow characteristics is of great significance for ensuring safety

energy saving

and the prevention of blockages in slurry transportation systems. To ensure safe and energy-efficient operation of the slurry transport system and prevent blockages

this study experimentally investigated the flow characteristics of slurry in pipelines and its critical Reynolds number (

). The focus is on analyzing the flow behavior of the slurry in the transition region

as well as the effects of the ice packing factor (IPF)

particle size

and pipe diameter on the slurry flow properties. The results show that the

increases with an increase in the IPF

while the

decreases with an increase in the pipe diameter and particle size. The flow regime transition of the slurry occurred within the Reynolds number (

) range of approximately 1 700-2 600. In the transition region

the resistance coefficient of the slurry first increases and then decreases as the

increases.

关键词

Keywords

references

朱桂华 , 洪泽玉 , 阮利超 , 等 . 水平90°弯管内盐泥浆输送压力损失研究 [J ] . 纯碱工业 , 2023 ( 1 ): 11 - 15 .

( ZHU Guihua , HONG Zeyu , RUAN Lichao , et al . Study on pressure loss of salt sludge conveying in horizontal 90 elbow [J ] . Soda Industry , 2023 ( 1 ): 11 - 15 .)

吕彤 , 胡琼 , 肖红 , 等 . U形弯管内大颗粒固液两相流的输送特性研究 [J ] . 矿冶工程 , 2019 , 39 ( 4 ): 6 - 10 .

( LYU Tong , HU Qiong , XIAO Hong , et al . Transport characteristics of large particles in U-shaped pipe [J ] . Mining and Metallurgical Engineering , 2019 , 39 ( 4 ): 6 - 10 .)

CAO Xuewen , YANG Kairan , BIAN Jiang . Investigation of CO 2 hydrate slurry flow characteristics with particle dissociation for carbon storage and transportation [J ] . Process Safety and Environmental Protection , 2021 , 152 : 427 - 440 .

CALATI M , RIGHETTI G , ZILIO C , et al . CFD analyses for the development of an innovative latent thermal energy storage for food transportation [J ] . International Journal of Thermofluids , 2023 , 17 : 100301 .

NTZIMANI A , ANGELAKOPOULOS R , SEMENOGLOU I , et al . Slurry ice as an alternative cooling medium for fish harvesting and transportation: study of the effect on seabass flesh quality and shelf life [J ] . Aquaculture and Fisheries , 2023 , 8 ( 4 ): 385 - 392 .

MINETTO S , FABRIS F , MARINETTI S , et al . A review on present and forthcoming opportunities with natural working fluids in transport refrigeration [J ] . International Journal of Refrigeration , 2023 , 152 : 343 - 355 .

杜群 , 宋文吉 , 肖睿 , 等 . 基于冰浆机与砖冰机结合的制冰方法及能耗研究 [J ] . 低温与超导 , 2021 , 49 ( 12 ): 78 - 84 .

( DU Qun , SONG Wenji , XIAO Rui , et al . Research on ice making method and energy consumption based on the combination of ice mortar machine and brick ice machine [J ] . Cryogenics & Superconductivity , 2021 , 49 ( 12 ): 78 - 84 .)

刘圣春 , 宋明 , 代宝民 , 等 . 管道内冰浆流动压降特性模拟和实验研究 [J ] . 制冷学报 , 2018 , 39 ( 2 ): 61 - 67 .

( LIU Shengchun , SONG Ming , DAI Baomin , et al . Numerical simulation and experimental study on flow pressure drop of ice slurry in piping systems [J ] . Journal of Refrigeration , 2018 , 39 ( 2 ): 61 - 67 .)

李伯 , 张红霞 , 莫伟南 . 弯管内减阻流体参数沿程变化模拟分析 [J ] . 中国科技论文 , 2019 , 14 ( 10 ): 1105 - 1110 .

( LI Bo , ZHANG Hongxia , MO Weinan . Simulation analysis of the variation of drag reduction fluid parameters along the curved pipe way [J ] . China Sciencepaper , 2019 , 14 ( 10 ): 1105 - 1110 .)

KUMAR B , MITTAL S . Prediction of the critical Reynolds number for flow past a circular cylinder [J ] . Computer Methods in Applied Mechanics and Engineering , 2006 , 195 ( 44-47 ): 6046 - 6058 .

LI F C , WANG D Z , KAWAGUCHI Y , et al . Simultaneous measurements of velocity and temperature fluctuations in thermal boundary layer in a drag-reducing surfactant solution flow [J ] . Experiments in Fluids , 2004 , 36 ( 1 ): 131 - 140 .

闫雪 , 张万松 , 邓佑鲜 , 等 . 垂直立管中下行颗粒流的雷诺数 [J ] . 中国粉体技术 , 2014 , 20 ( 6 ): 14 - 16 .

( YAN Xue , ZHANG Wansong , DENG Youxian , et al . Reynolds number of granular flow in standpipe [J ] . China Powder Science and Technology , 2014 , 20 ( 6 ): 14 - 16 .)

CAI Shupeng , HIGUCHI Y . Drag-reduction behavior of an unusual nonionic surfactant in a circular pipe turbulent flow [J ] . Journal of Hydrodynamics , 2014 , 26 ( 3 ): 400 - 405 .

田兴旺 , 张琨 , 王平 , 等 . 颗粒堆积多孔介质内幂律流体流动阻力模型 [J ] . 热科学与技术 , 2021 , 20 ( 2 ): 148 - 156 .

( TIAN Xingwang , ZHANG Kun , WANG Ping , et al . Flow resistance model of power law fluid flow through granular porous medium with wall effect [J ] . Journal of Thermal Science and Technology , 2021 , 20 ( 2 ): 148 - 156 .)

REZAEI M , ALI PAKRAVAN H . Thermo-fluidic characteristics of ice slurry flows in U-bend pipes for cold thermal energy storage [J ] . Journal of Energy Storage , 2023 , 57 : 106224 .

MI Sha , CAI Lingling , LUO Chun . Analysis on flow resistance of two-phase ice slurry in pulsating flow [J ] . Chemical Engineering Research and Design , 2022 , 186 : 485 - 496 .

MELLARI S . Experimental investigation and modeling of the pressure drop of ice slurry flow in horizontal pipe [J ] . International Journal of Refrigeration , 2023 , 147 : 134 - 142 .

IONESCU C , HABERSCHILL P , KISS I , et al . Local and global heat transfer coefficients of a stabilised ice slurry in laminar and transitional flows [J ] . International Journal of Refrigeration , 2007 , 30 ( 6 ): 970 - 977 .

NIEZGODA-ŻELASKO B , ZALEWSKI W . Momentum transfer of ice slurry flows in tubes, experimental investigations [J ] . International Journal of Refrigeration , 2006 , 29 ( 3 ): 418 - 428 .

GAO Penghui , LI Zhiyong , YAN Fuchun , et al . Study on flow and heat transfer characteristics of salt solution ice slurry [J ] . International Journal of Refrigeration , 2024 , 159 : 1 - 16 .

RAYHAN F A , YANUAR , PAMITRAN A S . Effect of ice mass fraction on ice slurry flow for cold energy storage application [J ] . Energy Reports , 2020 , 6 : 790 - 794 .

唐道轲 , 付林 , 杨波 , 等 . 大管径管道冰浆流动阻力特性实验研究 [J ] . 暖通空调 , 2023 , 53 ( 10 ): 115 - 119 .

( TANG Daoke , FU Lin , YANG Bo , et al . Experimental study on flow resistance characteristics of ice slurry in pipelines with large diameter [J ] . Journal of HV & AC , 2023 , 53 ( 10 ): 115 - 119 .)

梁运涛 , 王树刚 , 张腾飞 , 等 . 水平管道内冰浆流动阻力特性预测模型及比较 [J ] . 土木建筑与环境工程 , 2012 , 34 ( 6 ): 152 - 156 .

( LIANG Yuntao , WANG Shugang , ZHANG Tengfei , et al . Numerical modeling of ice slurry flow pressure drop in horizontal pipes [J ] . Journal of Chongqing Jianzhu University , 2012 , 34 ( 6 ): 152 - 156 .)

MONTEIRO A C S , BANSAL P K . Pressure drop characteristics and rheological modeling of ice slurry flow in pipes [J ] . International Journal of Refrigeration , 2010 , 33 ( 8 ): 1523 - 1532 .

MELLARI S . Experimental investigations of ice slurry flows in horizontal pipe based on monopropylene glycol [J ] . International Journal of Refrigeration , 2016 , 65 : 27 - 41 .

唐恒 , 章学来 , 王海民 . 基于冰晶结构的二元冰蓄冷系统中添加剂的研究 [J ] . 制冷空调与电力机械 , 2005 , 26 ( 1 ): 33 - 35 .

( TANG Heng , ZHANG Xuelai , WANG Haimin . Study on the additive in binary ice thermal storage system based on the structure of ice crystal [J ] . Refrigeration Air Conditioning and Electric Power Machinery , 2005 , 26 ( 1 ): 33 - 35 .)

MORIMOTO T , KOMATSU W , KIMATA H , et al . Solidification behavior of an ice slurry flowing in a rectangular channel [J ] . International Journal of Refrigeration , 2021 , 131 : 129 - 136 .

KITANOVSKI A , POREDOŠ A . Concentration distribution and viscosity of ice-slurry in heterogeneous flow [J ] . International Journal of Refrigeration , 2002 , 25 ( 6 ): 827 - 835 .

ETEMAD S G , SADEGHI M . Non-Newtonian pressure drop and critical Reynolds number through rectangular duct [J ] . International Communications in Heat and Mass Transfer , 2001 , 28 ( 4 ): 555 - 563 .

付朝波 , 宋鹏云 . 非接触机械密封端面间流体膜流动状态临界雷诺数的讨论 [J ] . 润滑与密封 , 2019 , 44 ( 7 ): 63 - 68 .

( FU Chaobo , SONG Pengyun . Discussion on critical Reynolds number of fluid film flow state between the non-contact mechanical seal faces [J ] . Lubrication Engineering , 2019 , 44 ( 7 ): 63 - 68 .)

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

冰浆在水平圆管过渡区内流动特性的影响因素

尿素溶液制备冰浆的流动特性研究

脉管制冷机波纹连管内交变流动及声功传输特性

大豆油微乳液冰浆融化与储存特性

超声场对过冷水溶液结晶的影响