人工造雪过程中喷嘴雾化特性的研究

李睿; 刘斌; 胡恒祥; 李卓睿; 曾涛

doi:10.12465/j.issn.0253-4339.2025.04.087

您当前的位置：

首页 >

文章列表页 >

人工造雪过程中喷嘴雾化特性的研究

更新时间：2025-08-28

- 人工造雪过程中喷嘴雾化特性的研究
- Study on Atomization Characteristics of Nozzles in Artificial Snow-Making Process
- 制冷学报 2025年46卷第4期页码：87-96
- 作者机构：
  
  天津商业大学　天津市制冷技术重点实验室　农业农村部农产品低碳冷链重点实验室　天津　300134
- 作者简介：
  
  刘斌，男，教授，天津商业大学机械工程学院，18920197448，E-mail：lbtjcu@tjcu.edu.cn。研究方向：制冷及低温工程技术，传热传质。
- 基金信息：
- DOI：10.12465/j.issn.0253-4339.2025.04.087
  中图分类号： TK124;TB657;P481
- 收稿日期：2024-05-08，
  
  修回日期：2024-05-24，
  
  录用日期：2024-07-31，
  
  纸质出版日期：2025-08-16
- 稿件说明：
移动端阅览
李睿, 刘斌, 胡恒祥, 等. 人工造雪过程中喷嘴雾化特性的研究[J]. 制冷学报, 2025,46(4):87-96.

Li Rui, Liu Bin, Hu Hengxiang, et al. Study on Atomization Characteristics of Nozzles in Artificial Snow-Making Process[J]. Journal of refrigeration, 2025, 46(4): 87-96.
李睿, 刘斌, 胡恒祥, 等. 人工造雪过程中喷嘴雾化特性的研究[J]. 制冷学报, 2025,46(4):87-96. DOI： 10.12465/j.issn.0253-4339.2025.04.087.

Li Rui, Liu Bin, Hu Hengxiang, et al. Study on Atomization Characteristics of Nozzles in Artificial Snow-Making Process[J]. Journal of refrigeration, 2025, 46(4): 87-96. DOI： 10.12465/j.issn.0253-4339.2025.04.087.

摘要

全球气候变暖及滑雪行业的蓬勃发展给人工造雪技术和造雪质量提出了更高要求，而人工造雪的质量与造雪喷嘴雾化特性密切相关。研究了不同喷嘴干涉作用和气液质量混合比（

glr

）对喷雾场液滴粒径分布和碰撞机制的影响。其中，喷嘴间距（

）代表喷嘴间的干涉程度，

glr

表示同一喷嘴下不同混合扰动程度。通过激光粒度测量仪和高速摄像机分别对喷雾场内液滴速度和粒径分布进行测量，并基于韦伯数（

）分析了喷雾场中液滴的破碎与碰撞。结果表明：不同间距下双喷嘴的流场轴向速度均大于单喷嘴的流场轴向速度，当

为10、15 cm时，轴向速度峰值分别为5.6、5.5 m/s。在液滴的破碎和聚并作用下，液滴粒径随着轴向距离增加，液滴尺寸先减小后增大。而双喷嘴喷雾场之间的干涉加剧了液滴的破碎碰撞，其

高于单喷嘴条件下

。分析不同布置条件下的双喷嘴流场发现，

glr

=0.10、

=15 cm时粒径分布较均匀。

Abstract

With global warming and the rapid growth of the ski industry

the demand for artificial snowmaking technology and improved snow quality has increased

both of which are closely linked to the atomization characteristics of snowmaking nozzles. In this study

the influences of different nozzle interferences and gas-liquid mass mixing ratios (

glr

) on the droplet size distribution and collision mechanism in a spray field were investigated. The nozzle spacing (

) represents the degree of interference between the nozzles

whereas

glr

signifies the varying degrees of mixing disturbance under identical nozzles. The velocity and size distribution of the droplets in the spray field were measured using a laser particle size measuring instrument and a high-speed camera

whereas the fragmentation and collision of the droplets in the spray field were analyzed b

ased on the Weber number (

). The results indicated that the axial velocity of double nozzles exceeded that of single nozzles at varying spacing intervals. Specifically

when the nozzle spacing was 10 cm and 15 cm

the peak axial velocities were recorded as 5.6 m/s and 5.5 m/s

respectively. The droplet size underwent a non-monotonic variation with the axial distance because of the competition between fragmentation and coalescence

which initially decreased before increasing. The interaction between the spray fields of the two nozzles enhanced the droplet collision

resulting in a higher

number than the individual nozzles. Analysis of the flow field of double nozzles under different arrangement conditions revealed that a higher level of uniformity in particle size distribution was observed when

glr

=0.10 and

=15 cm.

关键词

Keywords

references

董佩文 , 刘国强 , 张博文 , 等 . “冰雪魔术”变水成雪：人工造雪技术 [J ] . 科学通报 , 2022 , 67 ( 21 ): 2447 - 2449 .

( DONG Peiwen , LIU Guoqiang , ZHANG Bowen , et al . Magic of turning water into snow: artificial snowmaking technology [J ] . Chinese Science Bulletin , 2022 , 67 ( 21 ): 2447 - 2449 .)

杨占武 . 北京冬奥会和冬残奥会人工造雪的研究 [J ] . 冰雪运动 , 2017 , 39 ( 1 ): 1 - 8 .

( YANG Zhanwu . Research on the snow-making for Beijing 2022 winter olympics and winter Paralympics [J ] . China Winter Sports , 2017 , 39 ( 1 ): 1 - 8 .)

DAMM A , GREUELL W , LANDGREN O , et al . Impacts of +2 ℃ global warming on winter tourism demand in Europe [J ] . Climate Services , 2017 , 7 : 31 - 46 .

方琰 , SCOTT D , STEIGER R , 等 . 气候变化背景下人工造雪技术提升对中国滑雪季节长度的影响 [J ] . 资源科学 , 2020 , 42 ( 6 ): 1210 - 1222 .

( FANG Yan , SCOTT D , STEIGER R , et al . Impact of snow-making technology improvement on ski season length in China under climate change [J ] . Resources Science , 2020 , 42 ( 6 ): 1210 - 1222 .)

SHIN H T , LEE Y P , JURNG J . Spherical-shaped ice particle production by spraying water in a vacuum chamber [J ] . Applied Thermal Engineering , 2000 , 20 ( 5 ): 439 - 454 .

MIRABEDIN S M , FARHADI F . Numerical investigation of solidification of single droplets with and without evaporation mechanism [J ] . International Journal of Refrigeration , 2017 , 73 : 219 - 225 .

HONDO M . Snow making machine : JP2001—165542A [P ] . 2001-06-22 .

吴艳丽 , 王瑞祥 , 张华 , 等 . 室外造雪机用旋流喷嘴雾化性能实验研究 [J ] . 制冷学报 , 2023 , 44 ( 5 ): 116 - 122 .

( WU Yanli , WANG Ruixiang , ZHANG Hua , et al . Experimental study of spray performance of swirl nozzle in outdoor snow-makers [J ] . Journal of Refrigeration , 2023 , 44 ( 5 ): 116 - 122 .)

赵巍 , 汪惠荣 , 张华 , 等 . 内混式造雪机雪晶粒径分布实验研究 [J ] . 制冷学报 , 2023 , 44 ( 6 ): 125 - 130 .

( ZHAO Wei , WANG Huirong , ZHANG Hua , et al . Experimental study on distribution of snow grain size for internal mixing snow makers [J ] . Journal of Refrigeration , 2023 , 44 ( 6 ): 125 - 130 .)

LIU Bin , HU Hengxiang , BI Lisen , et al . Analysis of the characteristics of the gas-liquid mixed artificial snow-making [J ] . International Journal of Refrigeration , 2023 , 149 : 155 - 167 .

郝亚辉 , 吴海峰 , 张博文 , 等 . 室外造雪机用核子器雾化性能规律实验研究 [J ] . 制冷学报 , 2023 , 44 ( 1 ): 88 - 93 .

( HAO Yahui , WU Haifeng , ZHANG Bowen , et al . Experimental study on atomizing performance of nucleator nozzle for outdoor snow makers [J ] . Journal of Refrigeration , 2023 , 44 ( 1 ): 88 - 93 .)

LEE S , PARK S . Experimental study on spray break-up and atomization processes from GDI injector using high injection pressure up to 30 MPa [J ] . International Journal of Heat and Fluid Flow , 2014 , 45 : 14 - 22 .

吴海峰 , 刘佳维 , 王瑞祥 , 等 . 造雪机用旋流式喷嘴的雾化性能研究 [J ] . 制冷学报 , 2022 , 43 ( 6 ): 65 - 73 .

( WU Haifeng , LIU Jiawei , WANG Ruixiang , et al . Study of the atomization performance of swirl nozzle for snow-making machine [J ] . Journal of Refrigeration , 2022 , 43 ( 6 ): 65 - 73 .)

SAHA A , LEE J D , BASU S , et al . Breakup and coalescence characteristics of a hollow cone swirling spray [J ] . Physics of Fluids , 2012 , 24 ( 12 ): 124103 .

ZAREMBA M , WEIß L , MALY M , et al . Low-pressure twin-fluid atomization: effect of mixing process on spray formation [J ] . International Journal of Multiphase Flow , 2017 , 89 : 277 - 289 .

MOON S , HUANG Weidi , WANG Jin . Spray formation mechanism of diverging-tapered-hole GDI injector and its potentials for GDI engine applications [J ] . Fuel , 2020 , 270 : 117519 .

申力鑫 , 王成军 , 张中飞 , 等 . 基于PIV技术的喷雾场试验研究 [J ] . 沈阳航空航天大学学报 , 2017 , 34 ( 4 ): 27 - 33 .

( SHEN Lixin , WANG Chengjun , ZHANG Zhongfei , et al . Experimental study on spray field based on PIV technology [J ] . Journal of Shenyang Aerospace University , 2017 , 34 ( 4 ): 27 - 33 .)

ZHANG Bowen , WANG Ruixiang , WU Haifeng , et al . Atomization characteristics of twin nozzles for outdoor snow-makers application [J ] . International Journal of Refrigeration , 2022 , 139 : 60 - 69 .

PANCHAGNULA M V , SOJKA P E . Spatial droplet velocity and size profiles in effervescent atomizer-produced sprays [J ] . Fuel , 1999 , 78 ( 6 ): 729 - 741 .

LIU Bin , HU Hengxiang , BI Lisen , et al . Effect of the arrangement of two nozzles on morphology, velocity, and particle size distribution of artificial snow-making spray field [J ] . Physics of Fluids , 2023 , 35 ( 5 ): 053326 .

陈爱强 , 刘斌 , 李斌 , 等 . 气水混合式制雪机造雪性能实验研究 [J ] . 制冷技术 , 2020 , 40 ( 2 ): 64 - 68 .

( CHEN Aiqiang , LIU Bin , LI Bin , et al . Experimental study on snowmaking performance of gas-water hybrid snow machine [J ] . Chinese Journal of Refrigeration Technology , 2020 , 40 ( 2 ): 64 - 68 .)

WANG Ruixiang , ZHANG Bowen , XU Rongji , et al . Sensitivity of atomization characteristic to operation conditions for air-assisted atomizers in snow-makers [J ] . International Journal of Refrigeration , 2023 , 149 : 146 - 154 .

MLKVIK M , STÄHLE P , SCHUCHMANN H P , et al . Twin-fluid atomization of viscous liquids: the effect of atomizer construction on breakup process, spray stability and droplet size [J ] . International Journal of Multiphase Flow , 2015 , 77 : 19 - 31 .

ROESLER T C , LEFEBVRE A H . Studies on aerated-liquid atomization [J ] . International Journal of Turbo and Jet Engines , 1989 , 6 ( 3/4 ): 221 - 230 .

WHITLOW J D , LEFEBVRE A H . Effervescent atomizer operation and spray characteristics [J ] . Atomization and Sprays , 1993 , 3 ( 2 ): 137 - 155 .

曹建明 . 液体喷雾学 [M ] . 北京 : 北京大学出版社 , 2013 .

( CAO Jianming . Liquid sprays [M ] . Beijing : Peking University Press , 2013 .)

康金鑫 , 仝毅恒 , 黄柯嘉 , 等 . 离心式单、双喷嘴液膜破碎长度实验初步研究 [J/OL ] . 实验流体力学 , 1 - 7 [ 2024-05-05 ] . http://kns.cnki.net/kcms/detail/11.5266.V.20231030.1024.002.html http://kns.cnki.net/kcms/detail/11.5266.V.20231030.1024.002.html .

( KANG Jinxin , TONG Yiheng , HUANG Kejia , et al . Preliminary experimental study on the crushing length of centrifugal single and double injectors liquid film [J ] . Journal of Experiments in Fluid Mechanics , 1 - 7 [ 2024-05-05 ] . http://kns.cnki.net/kcms/detail/11.5266.V.20231030.1024.002.html http://kns.cnki.net/kcms/detail/11.5266.V.20231030.1024.002.html .)

LIU Cunxi , LIU Fuqiang , YANG Jinhu , et al . Experimental investigations of spray generated by a pressure swirl atomizer [J ] . Journal of the Energy Institute , 2019 , 92 ( 2 ): 210 - 221 .

张博文 . 水雾化过程多相流动及雾化规律探究 [D ] . 北京 : 北京建筑大学 , 2023 .

( ZHANG Bowen . Study on multiphase flow and atomization law in water atomization process [D ] . Beijing : Beijing University of Civil Engineering and Architecture , 2023 .)

GUILDENBECHER D R , LÓPEZ-RIVERA C , SOJKA P E . Secondary atomization [J ] . Experiments in Fluids , 2009 , 46 ( 3 ): 371 - 402 .

SOMMERFELD M , PASTERNAK L . Advances in modelling of binary droplet collision outcomes in sprays: a review of available knowledge [J ] . International Journal of Multiphase Flow , 2019 , 117 : 182 - 205 .

张雨树 , 薛雷平 . 液滴二次雾化破碎模式数值模拟 [J ] . 力学季刊 , 2015 , 36 ( 4 ): 574 - 585 .

( ZHANG Yushu , XUE Leiping . Numerical simulation of droplet breakup regimes in secondary atomization [J ] . Chinese Quarterly of Mechanics , 2015 , 36 ( 4 ): 574 - 585 .)

ASHGRIZ N , POO J Y . Coalescence and separation in binary collisions of liquid drops [J ] . Journal of Fluid Mechanics , 1990 , 221 : 183 - 204 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

人工造雪过程中喷嘴雾化特性的研究

气液混合式人工造雪喷雾场的全貌及粒径分布研究

内混式造雪机雪晶粒径分布实验研究