混合物R1234yf/R290和R1234ze（E）/R290的可燃极限研究

沈军; 黄宇杰; 钟权; 史贺纯; 李华杰; 赵桓

doi:10.12465/j.issn.0253-4339.2025.04.022

您当前的位置：

首页 >

文章列表页 >

混合物R1234yf/R290和R1234ze（E）/R290的可燃极限研究

更新时间：2025-08-28

- 混合物R1234yf/R290和R1234ze（E）/R290的可燃极限研究
- Research on the Flammability Limits of R1234yf/R290 and R1234ze(E)/R290 Mixtures
- 制冷学报 2025年46卷第4期页码：22-28
- 作者机构：
  
  珠海格力电器股份有限公司　珠海　519070
- 作者简介：
  
  钟权，男，高级工程师，珠海格力电器股份有限公司，0756-8587826，E-mail：zhongquan14@mails.ucas.ac.cn。研究方向：环保制冷剂。
- 基金信息：
- DOI：10.12465/j.issn.0253-4339.2025.04.022
  中图分类号： TB61⁺2;TB64
- 收稿日期：2024-03-25，
  
  修回日期：2024-07-18，
  
  录用日期：2024-07-23，
  
  纸质出版日期：2025-08-16
- 稿件说明：
移动端阅览
沈军, 黄宇杰, 钟权, 等. 混合物R1234yf/R290和R1234ze（E）/R290的可燃极限研究[J]. 制冷学报, 2025,46(4):22-28.

Shen Jun, Huang Yujie, Zhong Quan, et al. Research on the Flammability Limits of R1234yf/R290 and R1234ze(E)/R290 Mixtures[J]. Journal of refrigeration, 2025, 46(4): 22-28.
沈军, 黄宇杰, 钟权, 等. 混合物R1234yf/R290和R1234ze（E）/R290的可燃极限研究[J]. 制冷学报, 2025,46(4):22-28. DOI： 10.12465/j.issn.0253-4339.2025.04.022.

Shen Jun, Huang Yujie, Zhong Quan, et al. Research on the Flammability Limits of R1234yf/R290 and R1234ze(E)/R290 Mixtures[J]. Journal of refrigeration, 2025, 46(4): 22-28. DOI： 10.12465/j.issn.0253-4339.2025.04.022.

摘要

丙烷（R290）是一种极具潜力的家用空调替代制冷剂，但可燃性限制了其应用。根据ASHRAE 34-2022标准测试了R290、2

3-四氟丙烯（R1234yf）、反式-1

3-四氟丙烯（R1234ze（E））和二元混合物R1234ze（E）/R290、R1234yf/R290的可燃极限。分析了R1234yf和R1234ze（E）对R290可燃性的影响，并对比了R1234yf、R1234ze（E）、R32、R13I1和R134a对R290可燃性抑制能力。通过模拟计算了不同组分下R290混合物的制冷循环性能。结果表明：R1234yf和R1234ze（E）对R290可燃性的抑制能力相近且效果较差，当R1234yf和R1234ze（E）的质量分数达到80%时，混合物的可燃下限仅增加约1.0%。使用Le Chatelier模型对实验数据进行关联，计算结果与实验结果平均绝对偏差为0.57%。相比R290纯质，R1234ze（E）/R290与R1234yf/R290在共沸点附近的能效比衰减小于1%，单位容积制冷量增加小于0.4%。制冷剂对R290的燃烧抑制能力由大到小排序为：R13I1>R134a>R32>R1234ze（E）/R1234yf。

Abstract

Propane (R290) is a potential refrigerant substitute for household air conditioners. However

its flammability limits its application. In this study

the flammability limits of R290

3-tetrafluoropropene (R1234yf)

trans-1

3-tetrafluoropropene (R1234ze(E))

R1234ze(E)/R290

and R1234yf/R290 were determined according to the ASHRAE 34-2022 standard. The effects of R1234yf and R1234ze(E) on the flammability of R290 were analyzed

and the inhibiting abilities of R1234yf

R1234ze(E)

R32

R13I1

and R134a on the flammability of R290 were compared. In addition

the refrigeration cycle performance of R290 mixtures with different compositions was simulated. The results showed that both R1234yf and R1234ze(E) exhibited limited flame inhibition capabilities for R290. When the mass fractions of R1234yf and R1234ze(E) reached 80%

the lower flammability limit of the mixture increased by approximately 1.0%. The experimental data were correlated using the Le Chatelier model

which resulted in an average absolute deviation of 0.57% between the calculated and experimental results. Compared with R290

the energy efficiency ratio of the two refrigerants and R290 mixture decreased by less than 1%

and the volumetric cooling capacity increased by less than 0.4%. The flame inhibition effect of the refrigerant on R290 decreased in the following order: R13I1>R134a>R32>R1234ze(E)/R1234yf.

关键词

Keywords

references

奥维云网 . 2020年中国空调市场年度报告 [EB/OL ] ( 2021-01-21 ) [ 2024-03-15 ] . https://mp.weixin.qq.com/s/b5Xlvthh_bF5NmTlFD6RVg https://mp.weixin.qq.com/s/b5Xlvthh_bF5NmTlFD6RVg .

( AVC . 2020 China air conditioning market annual report [EB/OL ] . ( 2021-01-21 ) [ 2024-03-15 ] . https://mp.weixin.qq.com/s/b5Xlvthh_bF5NmTlFD6RVg https://mp.weixin.qq.com/s/b5Xlvthh_bF5NmTlFD6RVg .)

Designation and safety classification of refrigerants: ASHRAE 34-2022 [S ] . Atlanta : American National Standards Institute , 2022 .

解元飞 . R290应用于房间空调器的性能实验研究 [D ] . 武汉 : 华中科技大学 , 2015 .

( XIE Yuanfei . Experimental study on the performance of R290 applied to room air conditioner [D ] . Wuhan : Huazhong University of Science and Technology , 2015 .)

宁静红 , 刘圣春 , 彭苗 , 等 . R290制冷空调系统的现状与未来发展 [J ] . 流体机械 , 2012 , 40 ( 7 ): 72 - 79 .

( NING Jinghong , LIU Shengchun , PENG Miao , et al . Today and future development of R290 refrigeration and air-conditioning system [J ] . Fluid Machinery , 2012 , 40 ( 7 ): 72 - 79 .)

李小燕 , 宁前 , 何国庚 . 采用R290和R32的家用空调器全生命周期碳排放研究 [J ] . 低温工程 , 2021 ( 2 ): 33 - 40 .

( LI Xiaoyan , NING Qian , HE Guogeng . Study on carbon emission of household air conditioners using R290 and R32 as refrigerants in whole life cycle [J ] . Cryogenics , 2021 ( 2 ): 33 - 40 .)

陈志强 , 刘亚洲 . R290空调控制器的防爆设计及研究 [C ] // 2020年中国家用电器技术大会论文集 . 宁波 , 2020 : 797 - 801 .

( CHEN Zhiqiang , LIU Yazhou . Explosion-proof design and research of R290 air-conditioning controller [C ] // Proceedings of China Household Appliances Technology Conference 2020 . Ningbo , 2020 : 797 - 801 .)

ZHONG Quan , HUANG Yujie , ZHAO Huan , et al . Experimental study on the influence of trifluoroiodomethane on the flammability of difluoromethane and propane [J ] . International Journal of Refrigeration , 2022 , 135 : 14 - 19 .

CAI Dehua , HAO Zian , XU Hao , et al . Research on flammability of R290/R134a, R600a/R134a and R600a/R290 refrigerant mixtures [J ] . International Journal of Refrigeration , 2022 , 137 : 53 - 61 .

ZHONG Li , ZHANG Wang , LI Xing , et al . Effects of trifluoroiodomethane and pentafluoroethane on combustion characteristics of flammable refrigerant propane [J ] . International Journal of Refrigeration , 2023 , 148 : 25 - 34 .

MINOR B , SPATZ M . HFO-1234yf low GWP refrigerant update [C ] // Proceedings of the 12th International Refrigeration and Air Conditioning Conference . West Lafayette : Purdue University , 2008 : 937 - 944 .

KONDO S , TAKIZAWA K , TAKAHASHI A , et al . Flammability limits of olefinic and saturated fluoro-compounds [J ] . Journal of Hazardous Materials , 2009 , 171 ( 1/2/3 ): 613 - 618 .

KONDO S , TAKIZAWA K , TOKUHASHI K . Effects of temperature and humidity on the flammability limits of several 2L refrigerants [J ] . Journal of Fluorine Chemistry , 2012 , 144 : 130 - 136 .

KONDO S , TAKAHASHI A , TAKIZAWA K , et al . On the pressure dependence of flammability limits of CH 2 =CFCF 3 , CH 2 F 2 and methane [J ] . Fire Safety Journal , 2011 , 46 ( 5 ): 289 - 293 .

DONG Hanhai , LIU Yi , LI Yuxiao , et al . Effect of initial temperature on explosion characteristics of 2, 3, 3, 3-tetrafluoropropene [J ] . Journal of Loss Prevention in the Process Industries , 2020 , 68 : 104324 .

郭智恺 , 谢品赞 , 吴佳萍 . HFO-1234ze(E)在不同湿度下燃烧极限实验研究 [J ] . 浙江化工 , 2016 , 47 ( 3 ): 1 - 3 .

( GUO Zhikai , XIE Pinzan , WU Jiaping . Flammable limit study of HFO-1234ze(E) under different humidity [J ] . Zhejiang Chemical Industry , 2016 , 47 ( 3 ): 1 - 3 .)

LYU Zijian , YANG Zhao , CHEN Yubo , et al . Experimental studies on the flammability limit and burning velocity of the mixtures of 2, 3, 3, 3-tetrafluoroprop-1-ene [J ] . Fuel , 2021 , 298 : 120698 .

FENG Biao , YANG Zhao . Research on burning velocity of R152a and its binary mixture [J ] . Combustion and Flame , 2021 , 228 : 184 - 192 .

ZHANG Haiyang , ZHONG Quan , GONG Maoqiong , et al . Experimental study on the saturated liquid density and bubble point pressure for R1234ze(E) + R290 [J ] . Journal of Chemical & Engineering Data , 2016 , 61 ( 9 ): 3241 - 3249 .

ZHONG Quan , DONG Xueqiang , ZHAO Yanxing , et al . Thermodynamic properties of (R1234yf+R290): isochoric pρTx and specific heat capacity c v measurements and an equation of state [J ] . The Journal of Chemical Thermodynamics , 2019 , 129 : 36 - 43 .

ZHANG Nuochen , DAI Yuande . Performance evaluation of alternative refrigerants for R134a in automotive air conditioning system [J ] . Asia-Pacific Journal of Chemical Engineering , 2022 , 17 ( 1 ): e2732 .

ZHANG Nuochen , LI Biao , FENG Linghao , et al . Research on the thermophysical properties and cycle performances of R1234yf/R290 and R1234yf/R600a [J ] . International Journal of Thermophysics , 2021 , 42 ( 8 ): 123 .

LIANG Youcai , WU Jintao , SUN Zhili , et al . Thermodynamic and economic analysis of refrigerant mixture R290/R1234ze used in an ORC-EERC system for low temperature heat sources [J ] . Applied Thermal Engineering , 2023 , 229 : 120635 .

WANG Lele , LI Huixiong , WU Jiahuan , et al . Feasibility of using near-azeotropic refrigerant mixture R290/R1234ze(E) as substitute for R22 [J ] . Environmental Progress & Sustainable Energy , 2021 , 40 ( 3 ): e13574 .

王方 , 袁秋艳 , 王帅琪 , 等 . R1234ze/HCs非共沸混合工质热泵系统循环性能分析 [J ] . 制冷学报 , 2020 , 41 ( 1 ): 26 - 31 .

( WANG Fang , YUAN Qiuyan , WANG Shuaiqi , et al . Performance evaluation of heat pump system using non-azeotropic refrigerant blends R1234ze/HCs [J ] . Journal of Refrigeration , 2020 , 41 ( 1 ): 26 - 31 .)

LE CHATELIER H , BOUDOUARD O . Limits of flammability of gaseous mixtures [J ] . Bulletin de la Société Chimique de France (Paris) , 1898 , 19 : 483 - 488 .

ZHAO Zhen , LUO Jielin , ZOU Dexin , et al . Experimental investigation on the inhibition of flame retardants on the flammability of R1234ze(E) [J ] . Energy , 2023 , 263 : 126149 .

TAKAHASHI F , KATTA V R , LINTERIS G T , et al . Combustion inhibition and enhancement of cup-burner flames by CF 3 Br, C 2 HF 5 , C 2 HF 3 Cl 2 , and C 3 H 2 F 3 Br [J ] . Proceedings of the Combustion Institute , 2015 , 35 ( 3 ): 2741 - 2748 .

KONDO S , URANO Y , TOKUHASHI K , et al . Prediction of flammability of gases by using F-number analysis [J ] . Journal of Hazardous Materials , 2001 , 82 ( 2 ): 113 - 128 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

R245fa在丁胞型扁管内流动沸腾传热和压降特性的实验研究

制冷剂复合强化流动沸腾传热研究进展

绝热段阻力对CO₂、R134a和R410A分离式热管传热性能的影响

制冷剂回收与再生现状分析

基于统计数据的分体式空调系统泄漏点及成因分析