基于落塔实验的液氧气液界面形状演化特性研究

郭松源; 肖明堃; 岳莉; 罗威; 杜王芳; 赵建福; 杨光; 吴静怡

doi:10.12465/issn.0253-4339.20251119003

您当前的位置：

首页 >

文章列表页 >

基于落塔实验的液氧气液界面形状演化特性研究

低温技术 | 更新时间：2026-06-01

- 基于落塔实验的液氧气液界面形状演化特性研究
  增强出版
- Evolution of Liquid-Oxygen Interface Shape Based on Drop-Tower Experiments
- 制冷学报 2026年47卷第3期页码：1-8
- 作者机构：
  
  1.上海交通大学制冷与低温工程研究所上海 200240
  2. 中国科学院力学研究所北京 100190
- 作者简介：
  
  杨光，男，副教授，上海交通大学机械与动力工程学院，021-34206814，E-mail：y_g@sjtu.edu.cn。研究方向：低温流动与传热。Yang Guang， male， associate professor， School of Mechanical Engineering， Shanghai Jiao Tong University， 86-21-34206814，E-mail：y_g@sjtu.edu.cn. Research fields： flow and heat transfer of cryogenic fluids.
- 基金信息：
  
  国家自然科学基金(52276013)
- DOI：10.12465/issn.0253-4339.20251119003
  中图分类号： V511⁺.6;O363.2
- 收稿：2025-11-19，
  
  修回：2025-11-27，
  
  录用：2025-12-15，
  
  纸质出版：2026-06-16
- 稿件说明：
移动端阅览
郭松源,肖明堃,岳莉等.基于落塔实验的液氧气液界面形状演化特性研究[J].制冷学报,2026,47(03):1-8.

Guo Songyuan,Xiao Mingkun,Yue Li,et al.Evolution of Liquid-Oxygen Interface Shape Based on Drop-Tower Experiments[J].Journal of Refrigeration,2026,47(03):1-8.
郭松源,肖明堃,岳莉等.基于落塔实验的液氧气液界面形状演化特性研究[J].制冷学报,2026,47(03):1-8. DOI： 10.12465/issn.0253-4339.20251119003.

Guo Songyuan,Xiao Mingkun,Yue Li,et al.Evolution of Liquid-Oxygen Interface Shape Based on Drop-Tower Experiments[J].Journal of Refrigeration,2026,47(03):1-8. DOI： 10.12465/issn.0253-4339.20251119003.

摘要

在航天器深空探测任务中，低温推进剂贮箱内的流体常经历复杂的变过载环境，该过程中气液界面剧烈变化，引发强烈的相变传热与热力状态改变响应。本文基于落塔实验，搭建了液氧重定位实验系统，观测并记录了微重力转变过程中气液界面形态、气相温度与压强的动态变化。结果表明：在由常重力转为微重力的下落阶段，液氧三相接触线沿贮箱壁面爬升，并在首次回退时在壁面形成残留液体层。由于接触线爬升增大了气液界面面积，界面附近液氧持续蒸发，再叠加残留液体层的作用，最终使得增压速率上升。距离界面15.2 mm处的温度变化不仅受到固壁传热的影响，还受到界面振荡所引起的低温气体流动的干扰，在整个2.5 s的重定位过程中，该测点的温度增加量低于另外2只温度传感器。本研究为低温推进剂在轨管理装置的设计和重定位仿真模型的校验提供了重要的实验依据。

Abstract

Objective

To support complex aerospace missions including manned spaceflight， Mars exploration and space station construction， it is critical to conduct deep-space exploration research for solar-system planets and even extrasolar space. High-specific-impulse cryogenic fluids such as liquid hydrogen-liquid oxygen （LH

-LOX） and liquid oxygen-liquid methane （LOX-LCH

） are primary propellant for deep-space missions. During flight， cryogenic fluids in propellant tanks undergo gravity changes， leading to interface relocation. Owing to low surface tension and viscosity， their interfaces easily deform and break up， resulting in complicated flow behaviors. Meanwhile， increased interfacial and contact areas enhance heat transfer， triggering intense phase change due to low boiling points and latent heats， making thermal states unpredictable. This study aims to reveal the evolution of interface dynamics and thermal behavior during relocation， which is essential for the design of on-orbit propellant management devices.

Methods

In this study， a drop-tower experimental platform for LOX reorientation was constructed. The setup， housed in a stainless‑steel vacuum chamber with sapphire windows for optical access， uses multilayer insulation and combined LED l

ighting to enable high‑speed visualization. A liquid nitrogen cooling circuit connected via copper braids provides stable precooling and suppresses boiling. The test cell， made of sapphire with high pressure resistance， is instrumented with multiple temperature sensors. LOX is condensed and stabilized at a height of 18.5 mm until thermal drift is below 0.000 1 K/s. The system is then installed in the drop tower tube， adjusted for center‑of‑mass， and released from 83 m to generate nearly 3.5 s of microgravity at approximately 0.004 4

₀. High‑speed images are recorded and processed using a MATLAB edge‑detection algorithm to analyze interface evolution during the relocation process. Meanwhile， the vapor-phase temperature and pressure were measured. During the drop-tower process， the overload environment transitioned from normal gravity to microgravity.

Results and Discussions

The LOX propagated along the inner wall and formed a liquid layer. The motion of this liquid layer was decoupled from that of the bulk liquid， and the interface center oscillated continuously. Owing to the ascend of the contact line， the gas-liquid interface area increased， and LOX evaporated continuously at the contact line. The emergence of the liquid layer resulted in a pressurization rate of 3 227 Pa/s at the first oscillation of the contact line， which is approximately 1.8 times higher than the final stabilized pressurization rate. During the entire 2.5 s reorientation process， the pressure in the gas-phase region increased by 4 217 Pa. The temperature variation at 15.2 mm from the interface was affected by not only heat transfer from the solid wall but also disturbances from the low-temperature gas flow induced by interface oscillations. Additionally， the temperature at this measurement point increased by only 0.351 K during the entire reorientation process.

Conclusions

This study concludes that the evolution of the LOX interface， temperature and pressure in the ullage in the interface reorientation process. This experiment provides the cryogenic fluid data for simulation validation and guidance for the configuration and design of cryogenic-propellant management devices.

关键词

Keywords

references

郭松源，周晓庆，缪五兵，等 . 火箭上升段含多孔板液氧贮箱增压输运数值研究［J］. 化工学报， 2025 ， 76 （增刊1 ）： 62 - 74 .

GUO Songyuan ， ZHOU Xiaoqing ， MIAO Wubing ， et al . Numerical study on pressurized transport of liquid oxygen tank with perforated plate in rocket ascent stage ［J］. CIESC Journal ， 2025 ， 76 （ Suppl. 1 ）： 62 - 74 .

GUO Songyuan ， JIANG Zan ， LI Jianqiang ， et al . Numerical investigation on helium pressurization behavior of cryogenic propellant in microgravity ［J］. Applied Thermal Engineering ， 2025 ， 269 ： 125926 .

KULEV N ， BASTING S ， BÄNSCH E ， et al . Interface reorientation of cryogenic liquids under non-isothermal boundary conditions ［J］. Cryogenics ， 2014 ， 62 ： 48 - 59 .

GUO Songyuan ， XIAO Mingkun ， XIE Fang ， et al . Optimization of helium consumption for feedback pressurization in liquid oxygen tanks ［J］. International Journal of Heat and Mass Transfer ， 2024 ， 230 ： 125739 .

KÖNEMANN T ， KACZMARCZIK U ， GIERSE A ， et al . Concept for a next-generation drop tower system ［J］. Advances in Space Research ， 2015 ， 55 （ 6 ）： 1728 - 1733 .

MASICA W J ， PETRASH D A . Motion of liquid-vapor interface in response to imposed acceleration ［R］. Cleveland ： Lewis Research Center ， 1965 .

MICHAELIS M ， DREYER M E ， RATH H J . Experimental investigation of the liquid interface reorientation upon step reduction in gravity ［J］. Annals of the New York Academy of Sciences ， 2002 ， 974 ： 246 - 260 .

GERSTMANN J ， MICHAELIS M ， DREYER M . Capillary driven oscillations of a free liquid interface under non-isothermal conditions ［J］. Pamm ， 2004 ， 4 （ 1 ）： 436 - 437 .

GOVINDAN S N C ， DREYER M E . Experimental investigation of liquid interface stability during the filling of a tank in microgravity ［J］. Microgravity Science and Technology ， 2023 ， 35 （ 3 ）： 23 .

STIEF M ， GERSTMANN J ， DREYER M E . Reorientation of cryogenic fluids upon step reduction of gravity ［J］. Pamm ， 2005 ， 5 （ 1 ）： 553 - 554 .

KULEV N ， DREYER M . Drop tower experiments on non-isothermal reorientation of cryogenic liquids ［J］. Microgravity Science and Technology ， 2010 ， 22 （ 4 ）： 463 - 474 .

王峥，王晔，金鑫，等 . 网幕通道式液体获取装置的入口速度分布特性研究［J］. 真空与低温， 2022 ， 28 （ 5 ）： 556 - 564 .

WANG Zheng ， WANG Ye ， JIN Xin ， et al . Investigation on the velocity distribution in screen-channel liquid acquisition device ［J］. Vacuum and Cryogenics ， 2022 ， 28 （ 5 ）： 556 - 564 .

BELLUR K ， ME'DICI E F ， KULSHRESHTHA M ， et al . A new experiment for investigating evaporation and condensation of cryogenic propellants ［J］. Cryogenics ， 2016 ， 74 ： 131 - 137 .

范志杰，王俊表，陈来夫，等 . 北京落塔落舱质心快速测量与调整方法研究［J］. 力学与实践， 2025 ， 47 （ 4 ）： 754 - 758 .

FAN Zhijie ， WANG Junbiao ， CHEN Laifu ， et al . Methodology study on measurement and adjustment of drop capsule's centroid in the drop tower Beijing ［J］. Mechanics in Engineering ， 2025 ， 47 （ 4 ）： 754 - 758 .

王磊，贾洲侠，瞿淼，等 . 低温流体管理技术重力依赖性分析与微重力试验方案［J］. 制冷学报， 2021 ， 42 （ 4 ）： 1 - 11 .

WANG Lei ， JIA Zhouxia ， QU Miao ， et al . Gravity-dependence analysis of cryogenic fluid management techniques in space and experimental scheme suggestions ［J］. Journal of Refrigeration ， 2021 ， 42 （ 4 ）： 1 - 11 .

MICHAELIS M ， GERSTMANN J ， DREYER M E ， et al . Damping behavior of the free liquid interface oscillation upon step reduction in gravity ［J］. Proceedings in Applied Mathematics and Mechanics ， 2003 ， 2 （ 1 ）： 320 - 321 .

易天浩，邱一男，徐元元，等 . 微重力下低温流体动态毛细爬升的数值模拟［J］. 制冷学报， 2023 ， 44 （ 4 ）： 141 - 149 .

YI Tianhao ， QIU Yinan ， XU Yuanyuan ， et al . Numerical simulation of dynamic capillary rise with cryogenic fluids under microgravity ［J］. Journal of Refrigeration ， 2023 ， 44 （ 4 ）： 141 - 149 .

GERSTMANN J ， DREYER M E . Axisymmetric surface oscillations in a cylindrical container with compensated gravity ［J］. Annals of the New York Academy of Sciences ， 2006 ， 1077 （ 1 ）： 328 - 350 .

浏览量

583

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

除湿转轮的三维动态仿真与设计优化

静态条件下EL系列表面活性剂促进HCFC-141b水合物高密度蓄冷

多联机系统低GWP制冷剂替代及润滑油技术发展

热水长输供蒸汽吸收-压缩耦合高温热泵性能研究

集中空调系统末端研究现状与展望