基于场协同理论对高架立体医药库货架布置的优化研究

刘育栋; 管佳佳; 齐迪; 赵创要; 李安桂

doi:null

您当前的位置：

首页 >

文章列表页 >

基于场协同理论对高架立体医药库货架布置的优化研究

更新时间：2025-05-21

- 基于场协同理论对高架立体医药库货架布置的优化研究
- Optimization of Shelf Arrangement of High Rack Pharmaceutical Cold Store Based on Field Synergy Theory
- 默认刊物名称 2025年
- 作者机构：
  
  1.西安建筑科技大学建筑设备科学与工程学院西安 710055
  2.华商国际工程有限公司北京 100069
  3.西安交通大学能源与动力工程学院西安710049
  4.教育部低碳建筑环境国际合作联合实验室西安 710055
- 作者简介：
  
  齐迪，女，副教授，西安建筑科技大学建筑设备科学与工程学院，教育部低碳建筑环境国际合作联合实验室，15094052027，E-mail: qidi@xauat.edu.cn。研究方向：建筑及日光温室地热能应用，气流组织优化。
- 基金信息：
  
  本文受陕西省建筑设备科学与地下空间环境国际联合研究中心资助。（The project was supported by the International Joint Research Center for Building Service Science and Underground Space Environment, Shaanxi (China)）
- DOI：
  中图分类号： TB 657.1;TB657.5
- 稿件说明：
移动端阅览
刘育栋, 管佳佳, 齐迪, 等. 基于场协同理论对高架立体医药库货架布置的优化研究[J/OL]. 默认刊物名称, 2025.

Liu Yudong, Guan Jiajia, Qi Di, et al. Optimization of Shelf Arrangement of High Rack Pharmaceutical Cold Store Based on Field Synergy Theory[J/OL]. Moren journal, 2025.
刘育栋, 管佳佳, 齐迪, 等. 基于场协同理论对高架立体医药库货架布置的优化研究[J/OL]. 默认刊物名称, 2025. DOI：

Liu Yudong, Guan Jiajia, Qi Di, et al. Optimization of Shelf Arrangement of High Rack Pharmaceutical Cold Store Based on Field Synergy Theory[J/OL]. Moren journal, 2025. DOI：

摘要

高架立体医药库的热湿环境会影响药品的储存及疗效。本文以天津某高架立体医药冷库为研究对象，探讨不同货架布置对温湿度分布的影响。优化了冷库内部气流组织，并结合场协同理论，系统探讨了冷库的温湿度分布、温湿度均匀性及制冷效果。结果表明，场协同角可有效用于高架冷库的性能评价。适当增大货架层间距对于医药库的热性能有优化作用，当货架层间距为0.6m时，平均温度t

=4.56℃，温度不均匀系数K

=0.039，平均相对湿度55.21 %，相对湿度不均匀系数0.015，平均场协同角

= 57.47°，流动换热性能合理。本文将场协同角引入高架医药冷库优化研究，为医药库设计改进提供理论依据。

Abstract

The temperature and humidity distribution of the pharmaceutical warehouse will affect the efficacy of medicine. This paper takes an elevated stereoscopic medical cold storage in Tianjin to discuss the influence of different shelf layout on the distribution of temperature and humidity. The internal airflow distribution of the cold storage is optimized

and combined with the field coordination theory

the temperature and humidity distribution

temperature and humidity uniformity and refrigeration effect are systematically discussed. The results show that the field synergy angle can effectively be used to evaluate the performance of high rack cold store. Increasing the spacing between shelf layers optimizes the thermal performance of the pharmaceutical cold store. When the shelf layer spacing is 0.6 meters

the average temperature is 4.56°C

the temperature inhomogeneity coefficient (Kt) is 0.039

average relative humidity 55.21%

relative humidity inhomogeneity coefficient 0.015

and the average field synergy angle (α) is 57.47°

resulting in a more uniform and reasonable temperature field. In this paper

the field synergy Angle is introduced into the optimization research of elevated pharmaceutical cold storage

which provides a theoretical basis for the improvement of pharmaceutical storage design.

关键词

Keywords

references

中国物流与采购联合会医药物流分会 , 国药控股股份有限公司 . 中国医药物流发展报告(2024) ,[R ] . 北京 : 中国市场出版社， 2024 .

China Federation of Logistics and Purchasing Pharmaceutical Logistics Branch , Sinopharm Group Company Limited , Research report of Chinese pharmaceutical cold chain logistics industry( 2024 ), Beijing: China Market Press , 2024.

豆孟柯 , 刘宝林 , 宋晓燕 , 等 . 蓄冷箱在疫苗冷链中的研究进展 [J ] . 制冷学报 , 2019 , 40 ( 02 ): 138 - 141 .

DOU Mengke , LIU Baolin , SONG Xiaoyan , et al . Progress of cold storage tank in vaccine cold chain [J ] . Journal of Refrigeration , 2019 , 40 ( 02 ): 138 - 141 .

PAMBUDI N A , SARIFUDIN A , GANDIDI I M , et al . Vaccine cold chain management and cold storage technology to address the challenges of vaccination programs [J ] . Energy Reports , 2022 , 8 : 955 – 972 .

药品经营质量管理规范 [S ] . 北京：中华人民共和国国家食品药品监督管理总局， 2016 .

Good Supply Practice [S ] . Beijing : State Food and Drug Administration of the People's Republic of China , 2016 .

李艺哲 , 谢晶 . 大型冷库内温度场的数值模拟与优化 [J ] . 食品与机械 , 2017 , 33 ( 06 ): 139 - 142+179 .

LI Yizhe , XIE Jing . Numerical simulation and optimization of the temperature field in a large cold storage facility [J ] . Food and Machinery , 2017 , 33 ( 06 ): 139-142 + 179 .

QI Di , LIU Kexin , GUAN Jiajia , et al . Decision-making analysis of air supply strategies for high rack cold stores [J ] . Applied Thermal Engineering , 2022 , 217 : 119242 .

SAJADIYE S M , ZOLFAGHARI M . Simulation of in-line versus staggered arrays of vented pallet boxes for assessing cooling performance of orange in cool storage [J ] . Applied Thermal Engineering , 2017 , 115 : 337 - 349 .

WANG Guanbang , ZHANG Xinrong , Enhanced airflow by additional axial fans for produce cooling in a cold room : A numerical study on the trade-off between cooling performance and irreversibility [J ] . International Journal of Refrigeration , 2021 , 130 : 452 – 465

方蕾，赵娟，丁小磊，等 . 江苏某小型疫苗冷库热性能实测分析 [J ] . 中国设备工程 , 2021 , 12(上):196- 197 .

FANG Lei , ZHAO Juan , DING Xiaolei , et al . Measured analysis of thermal performance in a cold storage of a small vaccine in Jiangsu province [J ] . China Equipment Engineering 2021 , 12(first volume):196- 197 .

张皓月 , 张忠斌 , 顾呈华 , 等 . 2～8℃小型疫苗冷库热性能的实验及模拟 [J ] . 制冷学报 , 2020 , 41 ( 06 ): 140 - 149 .

ZHANG Haoyue , ZHANG Zhongbin , GU Chenghua , et al . 2~8℃ Experimental study and simulation of thermal performance in cold storage of small vaccine [J ] . Journal of Refrigeration , 2020 , 41 ( 06 ): 140 - 149 .

顾呈华 , 张皓月 , 张忠斌 , 等 . 小型疫苗冷库内部温度场试验研究 [J ] . 中国设备工程 , 2020 , ( 19 ): 77 - 79 .

GU Chenghua , ZHANG Haoyue , ZHANG Zhongbin , et al . Internal temperature field test study in small vaccine cold storage [J ] . China Equipment Engineering , 2020 ,( 19 ): 77 - 79 .

张皓月 . 2~8℃疫苗冷库热性能研究 ——以江苏省为例 [D ] . 南京师范大学， 2021 .

ZHANG Haoyue . 2~8 Study on thermal performance of ℃ vaccine cold storage — Taking Jiangsu Province as an example [D ] . Nanjing Normal University , 2021 .

胡佐新 . 药品冷库温度场的模拟及设计优化 [D ] . 贵州大学 , 2016 .

HU Zuoxin . Simulation and design optimization to temperature field of medicine cold storage [D ] . Guizhou University , 2016 .

胡佐新 , 黄爽 , 高欣 , 等 . 不同出风方式对冷库温度分布的影响 [J ] . 贵州大学学报 , 2016 , 33 ( 01 ): 39 - 41 .

HU Zuoxin , HUANG Shuang , GAO Xin , et al . The influence of different air outlet modes on the temperature distribution of cold storage [J ] . Journal of Guizhou University , 2016 , 33 ( 01 ): 39 - 41 .

屈治国，何雅玲，陶文铨，平直开缝翅片传热特性的三维数值模拟及场协同原理分析 [J ] . 工程热物理学报 , 2003 , 24 ( 05 ): 825 - 827 .

QU Zhiguo, HE Yaling, TAO Wenquan, 3D numerical simulation and principle analysis of field coordination [J ] . Journal of Engineering Thermophysics , 2003 , 24 ( 05 ): 825 - 827 .

张剑飞，陶文铨，何雅玲，螺旋折流板换热器的协同角分布特性及局部换热特征 [J ] . 化工学报 , 2013 , 64 ( 08 ): 2769 - 2773 .

ZHANG Jianfei, TAO Wenquan, HE Yaling, The synergistic Angle distribution characteristics and local heat transfer characteristics of the spiral folding flow plate heat exchanger [J ] . Journal of Chemical Industry , 2013 , 64 ( 08 ): 2769 - 2773

Qun Chen , Jianxun Ren , Zengyuan Guo , Field synergy analysis and optimization of decontamination ventilation designs [J ] , International Journal of Heat and Mass Transfer , 2008 , 51 : 873 – 881 .

高飞，张浩，王倩，基于场协同原理室内热舒适性模拟研究 [J ] . 洁净与空调技术 , 2020 , 2 : 24 - 28+33 .

GAO Fei, ZHANG Hao, WANG Qian, indoor thermal comfort simulation study based on the field collaboration principle [J ] . Contamination Control & Air-conditioning Technology , 2020 , 2 : 24 - 28+33 .

WANG Guanbang , ZHANG Xinrong , Enhancing uniformity of airflow and temperature distribution for produce cooling in a cold room based on field synergy principle [J ] . Journal of Enhanced Heat Transfer , 2021 , 28 ( 5 ): 39 – 60 .

HOANG H , DURET S , FLICK D , et al . Preliminary study of airflow and heat transfer in a cold room filled with apple pallets: Comparison between two modelling approaches and experimental results [J ] . Applied Thermal Engineerin , 2015 , 76 : 367 - 381 .

ALLEN K G , BACKSTRÖM T W , KRÖGER D G ， Packed bed pressure drop dependence on particle shape , size distribution , packing arrangement and roughness [J ] . Powder Technology , 2013 , 246 : 590 – 600 .

NAHOR H B , HOANG M L , VERBOVEN P , et al , CFD model of the airflow , heat and mass transfer in cool stores [J ] . International Journal of Refrigeration , 2005 , 28 ( 3 ): 368 – 380 .

陈孚江，黄丹丹，吴沁雨，等 . 等温环境下渗透式纤维空气分布系统CFD模型探讨 [J ] . 常州大学学报(自然科学版) , 2016 , 28 ( 02 ): 55 - 61 .

CHEN Fujiang , HUANG Dandan , WU Qinyuan , et al . On the CFD model of osmotic fiber air distribution system in isothermal environment [J ] . Journal of Changzhou University (Natural Science Edition) , 2016 , 28 ( 02 ): 55 - 61 .

冷库设计标准： GB50072-2021 [S ] , 中国国家标准, 2021 .

Cold Storage Design Standard : GB50072-2021 [S ] , Chinese National Standard, 2021 .

胡艳，蒋国强，熊亮，等 . 基于CFD的猕猴桃冷库流场模 [J ] . 农机化研究 , 2012 , 34 ( 05 ): 155 - 159 .

HU Yan , JIANG Guoqiang , XIONG Liang , et al . Flow field simulation of kiwi fruit cold storage based on CFD [J ] . Agricultural mechanization research , 2012 , 34 ( 05 ): 155 - 159 .

PRAEGER U , JEDERMANN R , SELLWIG M , et al . Airflow distribution in an apple storage room [J ] . Journal of Food Engineering , 2020 , 269 : 109746

LI Mingliang , ZHAO Yanan , LONG Rui , et al . Field synergy analysis for heat and mass transfer characteristics in adsorption-based desalination and cooling systems [J ] . Desalination , 2021 , 517 : 115244

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

２~８℃小型疫苗冷库热性能的实验及模拟

疫苗冷藏车热性能影响因素实测研究