Study on Application Scope for CO2 Cascade Refrigeration System and CO2 Secondary Refrigerant System

Tian Yafen; Zhao Zhaorui; Xing Ziwen; Yang Yifan; Ma Jin; Yu Zhiqiang

doi:10.3969/j.issn.0253-4339.2016.02.022

您当前的位置：

首页 >

文章列表页 >

Study on Application Scope for CO2 Cascade Refrigeration System and CO2 Secondary Refrigerant System

更新时间：2024-07-18

- Study on Application Scope for CO2 Cascade Refrigeration System and CO2 Secondary Refrigerant System
- Journal of Refrigeration Vol. 37, Issue 2, (2016)
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院
  2. 中国制冷学会秘书处
  3. 国内贸易工程设计研究院
  4. 烟台冰轮股份有限公司
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2016.02.022
  CLC：
- Published：2016，
- 稿件说明：
移动端阅览
TIAN YAFEN, ZHAO ZHAORUI, XING ZIWEN, et al. Study on Application Scope for CO2 Cascade Refrigeration System and CO2 Secondary Refrigerant System. [J]. Journal of refrigeration, 2016, 37(2).
DOI：

TIAN YAFEN, ZHAO ZHAORUI, XING ZIWEN, et al. Study on Application Scope for CO2 Cascade Refrigeration System and CO2 Secondary Refrigerant System. [J]. Journal of refrigeration, 2016, 37(2). DOI： 10.3969/j.issn.0253-4339.2016.02.022.

摘要

鉴于自然工质制冷剂具有优良的环保特性，相关技术的推广应用越来越多地受到人们的关注，其中CO2与NH3被视为是最适合且最有潜力的自然工质。在冷冻冷藏领域，工业界和学术界使用最为广泛的制冷系统——NH3/CO2复叠制冷系统与NH3压缩CO2载冷剂制冷系统，这两种系统应用的工况范围并没有得到清晰而广泛的共识。对此，本文在常规商业冷冻冷藏应用温度区间内，分别对NH3/CO2复叠制冷系统及NH3压缩CO2载冷剂制冷系统的制冷性能进行分析，并结合实际工程应用条件，得出CO2复叠制冷系统与载冷剂制冷系统各自适合的工作范围，旨在为CO2制冷系统的合理应用提供参考。研究表明，在需求蒸发温度低于-25 ℃的场合宜采用NH3/CO2复叠制冷系统作为供冷系统，并且对于CO2压缩机，最高吸气压力应不小于1.97 MPa，CO2压缩机的最高允许排气压力也应大于4.07 MPa。

Abstract

The employment of natural refrigerant have drawn widespread attention

since natural refrigerant are completely environmentally friendly and they have high potential in refrigeration application. Among them

the NH3/CO2 cascade refrigeration system and NH3 compression refrigeration system with CO2 as secondary refrigerant have been viewed as the most promising refrigeration methods in freezer and cold storage especially. Nevertheless

there is limited agreement on the scope of application for these two types of system since no strictly related investigation has been conducted. In this paper

the refrigeration performance of the two systems above is analyzed

and conclusion is drawn on the basis of practical engineering applications. The range of application for these two types of system is marked off and explained in detail

aiming at providing reasonable suggestion for design and optimization of CO2 refrigeration systems in the future. It is shown that NH3/CO2 cascade refrigeration system is more competitive when the evaporating temperature is below -25 ℃

and the maximum suction pressure and and the maximum discharge pressure of CO2 compressor should not be lower than 1.97 MPa and 4.07 MPa respectively.

关键词

CO2复叠制冷系统CO2载冷剂制冷系统适用范围自然工质制冷性能CO2压缩机

Keywords

CO2 cascade refrigeration systemCO2 secondary refrigerantapplication scopenatural refrigerantrefrigeration performanceCO2 compressor

references

Views

2800

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Performance of Low-temperature Two-stage Transcritical CO₂ Compression Refrigeration System with Ejector

批量制备La-Fe-Si系磁热材料的磁热性能和制冷性能研究

Experimental Research on Refrigeration Performance of Quick Freezer

Effect of Pore Structure Distribution on Adsorption Refrigeration with Activated Carbon–Methanol Working Pair

Analysis of the Refrigeration Performance and Main Influencing Factors of Multi-stage Thermoelectric Coolers

Related Author

Jiao Xingrong

Ye Fangping

Zhang Liang

Fu Bing

Yang Yuqi

刘翠兰

郭亚茹

黄焦宏

Related Institution

School of Energy and Power Engineering, University of Shanghai for Science and Technology

Zhejiang Xinjin Air Conditioning Equipment Co., Ltd.

包头稀土研究院白云鄂博稀土资源研究与综合利用全国重点实验室

School of Electric Power，South China University of Technology

State Key Lab of Subtropical Building Science, South China University of Technology

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰