Experimental Study of Flow Boiling Heat Transfer Performance in High Aspect Ratio Microchannels

Zhu Xueyue; Huang Tao; Li Meiyong; Liu Zeyu; Shen Limei; Liu Zhichun

doi:10.12465/issn.0253-4339.20251117001

您当前的位置：

首页 >

文章列表页 >

Experimental Study of Flow Boiling Heat Transfer Performance in High Aspect Ratio Microchannels

更新时间：2026-04-24

- Experimental Study of Flow Boiling Heat Transfer Performance in High Aspect Ratio Microchannels
- Journal of Refrigeration Pages: 1-7(2026)
- 作者机构：
  
  华中科技大学能源与动力工程学院武汉 430074
- 作者简介：
- 基金信息：
  
  the National Natural Science Foundation of China(52176007)
- DOI：10.12465/issn.0253-4339.20251117001
  CLC： TB657.5;TK124;O359⁺.1
- Received：17 November 2025，
  
  Revised：2026-01-04，
  
  Accepted：13 January 2026，
  
  Online First：24 April 2026，
- 稿件说明：
移动端阅览
朱学跃,黄涛,李美勇等.大高宽比微通道流动沸腾传热特性实验研究[J].制冷学报,

Zhu Xueyue Huang Tao Li Meiyong Liu Zeyu Shen Limei Liu Zhichun.Experimental Study of Flow Boiling Heat Transfer Performance in High Aspect Ratio Microchannels[J].Journal of Refrigeration,
朱学跃,黄涛,李美勇等.大高宽比微通道流动沸腾传热特性实验研究[J].制冷学报, DOI：10.12465/issn.0253-4339.20251117001.

Zhu Xueyue Huang Tao Li Meiyong Liu Zeyu Shen Limei Liu Zhichun.Experimental Study of Flow Boiling Heat Transfer Performance in High Aspect Ratio Microchannels[J].Journal of Refrigeration, DOI：10.12465/issn.0253-4339.20251117001.

摘要

为研究大高宽比微通道流动沸腾传热特性，本文以高宽比为18、基材为紫铜的微通道散热器为实验对象，搭建性能测试实验平台，实验研究了持续和间歇2种热源加热模式下微通道散热器温度流动响应与散热特性。结果表明：在持续加热300 W/cm

与间歇加热750 W/cm

-加热时间90 s条件下，该微通道散热器表现出良好的两相传热性能，热源面稳定温度能够控制在75 ℃水平内，进出口压降维持在约18 kPa。流量与微通道进出口压降之间存在较强的正相关关系。

Abstract

In this study， we analyzed the flow-boiling heat transfer behavior of a copper microchannel heat sink with a high geometric aspect ratio of 18. An experimental platform was established to systematically evaluate the thermohydraulic response and heat dissipation capability under two heating regimes： continuous and intermittent. In the continuous mode with a heat flux of 300 W/cm² and in the intermittent mode with 750 W/cm² for 90 s， the heat sink successfully maintained the heat-source surface temperature below 75 ℃， while the inlet-outlet pressure drop remained around 18 kPa， indicating excellent two-phase thermal and hydraulic performance. In addition， the flow rate and microchannel pressure drop exhibited a strong positive correlation.

关键词

Keywords

references

Shang Huiqing ， Xia Guodong ， Zhou Wenbin ， et al . Experimental study on flow boiling heat transfer in sudden expansion variable cross-section bi-porous minichannels ［J］. Applied Thermal Engineering ， 2025 ， 280 ： 128486 .

Choi T ， Kim T Y . Flow boiling performance of T-shaped microchannels with sudden-expansion flow passages ［J］. Applied Thermal Engineering ， 2025 ， 274 ： 126568 .

栗庆文 . 矩形微通道热沉强化传热及实验研究［D］. 济南：山东大学， 2024 .

Li Qingwen . Heat transfer enhancement and experiment researches on the rectangular microchannel heat sink ［D］. Jinan ： Shandong University ， 2024 .

薛丽红 . 高纵横比微通道内部的毛细流动及毛细蒸发研究［D］. 济南：山东大学， 2023 .

Xue Lihong . Research on capillary flow and capillary evaporation in high aspect ratio microchannels ［D］. Jinan ： Shandong University ， 2023 .

王琛 . 基于CPU散热的微通道强化传热数值模拟与实验研究［D］. 徐州：中国矿业大学， 2022 .

Wang Chen . Numerical and experimental study on heat transfer enhancement of CPU cooling based on microchannel ［D］. Xuzhou ： China University of Mining and Technology ， 2022 .

庄晓如，李翔，杨智 . 微通道液液两相弹状流传热的研究进展［J］. 制冷学报， 2025 ， 46 （ 6 ）： 1 - 10 .

Zhuang Xiaoru ， Li Xiang ， Yang Zhi . Research progress on heat transfer of liquid-liquid two-phase slug flow in microchannels ［J］. Journal of Refrigeration ， 2025 ， 46 （ 6 ）： 1 - 10 .

Long Jiangyou ， Liu Ziyin ， Lin Huipeng ， et al . Pool boiling heat transfer and bubble dynamics over V-shaped microchannels and micropyramids： Does high aspect ratio always benefit boiling？［J］. Applied Thermal Engineering ， 2022 ， 201 ： 117796 .

Cheng Xiao ， Pan Shanshan ， Zhou Yuan ， et al . Deionized water flow boiling in low-surface-roughness silicon-based high aspect ratio interconnected microchannels ［J］. International Journal of Heat and Mass Transfer ， 2025 ， 238 ： 126454 .

Cheng Xiao ， Wu Huiying . Improved flow boiling performance in high-aspect-ratio interconnected microchannels ［J］. International Journal of Heat and Mass Transfer ， 2021 ， 165 ： 120627 .

Cheng Xiao ， Wu Huiying . Enhanced flow boiling performance in high-aspect-ratio groove-wall microchannels ［J］. International Journal of Heat and Mass Transfer ， 2021 ， 164 ： 120468 .

Kim B . An experimental study on fully developed laminar flow and heat transfer in rectangular microchannels ［J］. International Journal of Heat and Fluid Flow ， 2016 ， 62 ： 224 - 232 .

Shah N ， Mehta H B ， Banerjee J . Synchronized visualization and thermal measurements of flow boiling in high-aspect-ratio microchannel with backflow controller ［J］. International Journal of Multiphase Flow ， 2025 ， 185 ： 105140 .

Pan Yuhui ， Zhao Rui ， Fan Xihui ， et al . Study on the effect of varying channel aspect ratio on heat transfer performance of manifold microchannel heat sink ［J］. International Journal of Heat and Mass Transfer ， 2020 ， 163 ： 120461 .

Wang Yuan ， Sefiane K ， Harmand S . Flow boiling in high-aspect ratio mini- and micro-channels with FC-72 and ethanol： Experimental results and heat transfer correlation assessments ［J］. Experimental Thermal and Fluid Science ， 2012 ， 36 ： 93 - 106 .

Cui Peilin ， Liu Zhenyu ， Wu Huiying . Subcooled flow boiling in ultrahigh-aspect-ratio microchannels for high heat flux cooling ［J］. International Communications in Heat and Mass Transfer ， 2024 ， 151 ： 107221 .

Cui Peilin ， Liu Zhenyu . Experimental study on flow boiling in ultrahigh-aspect-ratio copper microchannel heat sink ［J］. Applied Thermal Engineering ， 2023 ， 223 ： 119975 .

王志远 . 底部带团簇微柱阵列的高宽深比微通道内流动沸腾换热特性实验研究［D］. 镇江：江苏大学， 2024 .

Wang Zhiyuan . Experimental study on flow boiling heat transfer characteristics in microchannels with bottom-distributed clustered micro-pin arrays of high aspect ratio ［D］. Zhenjiang ： Jiangsu University ， 2024 .

Views

236

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Simulation and Experimental Study of a Thermoelectric Refrigeration Thermal Management System Based on Flat Heat Pipes

Experimental Study on Passive Thermal Management of Automotive Fuel Cell Stacks based on Vapor Chamber

Performance Evaluation and Optimization Study of Photovoltaic Modules Incorporating Radiative Cooling Films

Research Progress of Liquid Jet Cooling for High Heat Flux Devices

Investigating the Thermal Management System of eVTOL Flying Car in Future Urban Air Mobility Application

Related Author

Chen Chong

Liu Kehan

Shi Bo

Chen Zhaobin

Yang Xianfei

Cai Jun

Bai Xingying

Zhang Ruohui

Related Institution

College of Energy and Power Engineering, Nanjing University of Aeronautics and Astronautics

China National Electric Apparatus Research Institute Co.， Ltd.

CVC Testing Technology Co.， Ltd.

School of Electrical Engineering， Xinjiang University

Engineering Research Center of Northwest Energy Carbon Neutrality， Ministry of Education

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰

AI伴读