1,21,2&lt;p&gt;Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery&lt;br&gt;&lt;/p&gt;

CHEN Qinghua; WU Ruilong

您当前的位置：

首页 >

文章列表页 >

^1,2^1,2Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery

更新时间：2025-04-17

- ^1,2^1,2Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery 
- Journal of refrigeration (2025)
- 作者机构：
 
 1.安徽理工大学机电工程学院,安徽省淮南市232001
 2.合肥综合性国家科学中心能源研究院,安徽省合肥市230001,中国
- 作者简介：
- 基金信息：
 
 the National Natural Science Foundation of China(52175070)
- DOI：
 CLC： TB61⁺1;TM912
- Received：31 December 2024，
 
 Revised：2025-03-17，
 
 Accepted：08 April 2025，
- 稿件说明：
移动端阅览
CHEN Qinghua, WU Ruilong. ^1,2^1,2Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery [J/OL]. Journal of refrigeration, 2025.
DOI：

CHEN Qinghua, WU Ruilong. ^1,2^1,2Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery [J/OL]. Journal of refrigeration, 2025. DOI：

摘要

为探究冷媒相变对锂离子电池温控的影响规律，采用数值模拟的方法进行研究。本文制定直冷系统散热方案，建立电热耦合模型模拟电池生热，采用Lee模型模拟冷媒相变过程。并利用实验对模型可靠性进行验证，误差在3%以内。对不同工况下的直冷系统进行数值模拟，分析口琴式冷板的不同边界条件、并联式和蛇形冷板的流道结构对直冷系统温控性能的影响。结果表明：2倍率工况下，直冷系统最高温度及温差分别比液冷系统降低了7.12%和58.86%。蒸发温度从10℃上升到20℃时，直冷板内部压差从45.74Pa下降到39.48Pa，较低的蒸发温度可以促进冷媒相变。入口处液相分数的升高有利于降低电池模组的最高温度，却会导致电池模组温差增大和液相冷媒过剩。增加流道与电池底部有效接触面有助于电池散热，延长流道长度有利于冷媒充分相变。

Abstract

To investigate the impact of refrigerant phase change on lithium-ion battery temperature control

numerical simulation was employed. A direct cooling system was designed and an electro-thermal model was established to simulate heat generation in batteries. The Lee model was used for the phase change simulation. Model reliability was confirmed with experiments

with errors kept under 3%. Simulations were conducted for various conditions to analyze the effects of different boundary conditions on a harmonica-style cold plate and the flow channel structures of parallel and serpentine cold plates on the cooling performance. Results indicated that at a 2C rate

the direct cooling system's max temp and temp diff are 7.12% and 58.86% lower than the liquid cooling system. When evaporation temp rises from 10℃ to 20℃

the direct cooling plate's pressure diff drops from 45.74Pa to 39.48Pa. Lower evaporation temp aids refrigerant phase transition. An increased liquid phase fraction at the inlet can lower the battery module's highest temperature but may lead to greater temperature differences and excess liquid refrigerant. Increasing the flow channel's effective contact area with the battery bottom aids in cooling

and extending the channel length promotes complete refrigerant phase change.

关键词

Keywords

references

刘明明 . “双碳”目标下可再生能源发展规划实施的用地困境及其纾解 [J ] . 中国人口·资源与环境 , 2022 , 32 ( 12 ): 21 - 30 .

LIU Mingming . The land dilemma of renewable energy development planning under the goal of "double carbon" and its relief [J ] . Population, Resources and Environment of China , 20221 , 32 ( 12 ): 21 - 30 .

周天舒 , 迟东训 , 等 . 双碳背景下可再生能源面临的挑战及对策建议 [J ] . 宏观经济管理 , 2022 ,( 07 ): 59 - 65 .

ZHOU Tianshu , CHI Dongxun , et al . Challenges and countermeasures of renewable energy under the background of double carbon [J ] . Macroeconomic Management , 2022 , ( 07 ): 59 - 65 .

LIU Jialong , ZHANG Yun , et al . Influencing factors of lithium-ion battery thermal runaway in confined space [J ] . Journal of Energy Storage , Volume 73, Part D, 2023 , 109125, ISSN 2352 - 152 X.

廖正海 , 张国强 . 锂离子电池热失控早期预警研究进展 [J ] . 电工电能新技术 , 2019 , 38 ( 10 ): 61 - 66 .

LIAO Zhenghai , ZHANG Guoqiang . Research Progress on Early Warning of Lithium-ion Battery Thermal Runaway [J ] . New Technology of Electrical and Energy , 2019 , 38 ( 10 ): 61 - 66 .

SATYA PRAKASH VERMA , SAMIR SARASWATI , Numerical and experimental analysis of air-cooled Lithium-ion battery pack for the evaluation of the thermal performance enhancement [J ] . Journal of Energy Storage , Volume 73, Part B, 2023 ,108983,ISSN 2352 - 152 X.

ZHENDONG Z , LINXIANG F , et al . Method of liquid-cooled thermal control for a large-scale pouch lithium-ion battery [J ] . Applied Thermal Engineering , 2022 , 211 .

YUAN G , QING G , et al . Study on battery directcooling coupled with air conditioner novel system and control method [J ] . Journal of Energy Storage , 2023 , 70

杨世春 , 周思达 , 等 . 车用锂离子电池直冷热管理系统用冷媒研究进展 [J ] . 北京航空航天大学学报 , 2019 , 45 ( 11 ): 2123 - 2132 .

YANG Shichun , ZHOU Sida , et al . Research Progress on Refrigerants for Direct Cooling Thermal Management Systems of Lithium-ion Batteries in Vehicles [J ] . Journal of Beijing University of Aeronautics and Astronautics , 2019 , 45 ( 11 ): 2123 - 2132 .

黄伟 . 动力电池直冷直热板的设计及优化研究 [D ] . 山东大学 , 2023 .

HUANG Wei . Design and optimization of direct cooling and hot plate for power battery [D ] . Shandong University , 2023 .

TANG A , YANG J , et al . Optimization and working performance analysis of liquid cooling plates in refrigerant direct cooling power battery systems [J ] . International Journal of Heat and Mass Transfer , 2024 , 231125899 - 125899 .

宋旭 , 孙楠楠 , 等 . 基于并联蛇形流道的动力电池冷媒直冷热管理系统研究 [J ] . 储能科学与技术 , 2024 , 13 ( 08 ): 2726 - 2736 .

SONG Xu , SUN Nannan , et al . Research on direct cooling and heat management system of power battery refrigerant based on parallel serpentine channel [J ] . Energy Storage Science and Technology , 2024713 ( 08 ): 2726 - 2736

赵金辉 , 姜冰 , 等 . 基于双置直冷板技术的动力电池热管理系统性能研究 [J ] . 低温工程 , 2023 ,( 06 ): 50 - 57 .

ZHAO Jinhui , JIANG Bing , et al . Study on the performance of power battery thermal management system based on double direct cooling plate technology [J ] . Cryogenic Engineering , 2023 , ( 06 ): 50 - 57 .

聂磊 , 王敏弛 , 等 . 纯电动汽车冷媒直冷电池热管理系统的实验研究 [J ] . 制冷学报 , 2020 , 41 ( 04 ): 52 - 58 .

NIE Lei , WANG Minchi , et al . Experimental Study on Direct Media Cooling Thermal Management System for Battery in Pure Electric Vehicles [J ] . Refrigeration , 2020 , 41 ( 04 ): 52 - 58 .

高帅 , 王俊博 , 等 . 基于二次节流的电池直冷系统设计与分析 [J ] . 低温与超导 , 2023 , 51 ( 05 ): 56 - 63, 89 .

GAO Shuai , WANG Junbo , et al . Design and Analysis of a Battery Direct Cooling System Based on Secondary Throttling [J ] . Cryogenics and Superconductivity , 2023 , 51 ( 05 ): 56 - 63, 89 .

GUO Jian , JIANG Fangming . A novel electric vehicle thermal management system based on cooling and heating of batteries by refrigerant [J ] . Energy Conversion and Management , 2021 , 237 .

Luyao Z , Wei L , Guoyang W , et al . A novel thermal management system for lithium-ion battery modules combining direct liquid-cooling with forced air-cooling [J ] . Applied Thermal Engineering , 2023 , 232

杨玉荣 , 王世学 , 等有限空间内气液相变传热特性的实验研究 [J ] . 工程热物理学报 , 2023 , 44 ( 12 ): 3380 - 3386 .

YANG Yurong , WANG Shixue , et al . Experimental study on heat transfer characteristics of gas-liquid phase change in limited space [J ] . Journal of Engineering Thermophysics , 2023 ,44, 12 : 3380 - 3386 .

封居强 , 司玉文 , 等 . 基于动态综合型等效电路模型的动力电池特性分析 [J ] . 储能科学与技术 , 2020 , 9 ( 03 ): 986 - 992 .

FENG Juqiang , SI Yuwen , et al . Dynamic Comprehensive Equivalent Circuit Model-Based Analysis of Power Battery Characteristics [J ] . Energy Storage Science and Technology , 2020 , 9 ( 03 ): 986 - 992 .

黄敬源 . 基于锂电池电化学模型功率状态估计的模型预测方法研究 [D ] . 西南交通大学 , 2022 .

HUANG Jingyuan . Study on model prediction method based on power state estimation of electrochemical model of lithium battery [D ] . Southwest Jiaotong University , 2022 .

程夕明 , 唐宇 , 等 . 锂离子电池热物性参数测量方法综述 [J ] . 机械工程学报 , 2019 , 55 ( 14 ): 140 - 150 .

CHENG Ximing , TANG Yu , et al . Journal of Mechanical Engineering , 2019 , 55 ( 14 ): 140 - 150 .

高帅 , 王俊博 , 等 . 制冷剂相态变化对动力电池直冷系统温控性能的影响分析 [J ] . 制冷学报 , 2023 , 44 ( 3 ): 58 - 66, 80 .

GAO Shuai , WANG Junbo , et al . Analysis of the Impact of Refrigerant Phase Change on the Temperature Control Performance of Direct Cooling Systems for Power Batteries [J ] . Refrigeration , 2023 , 44 ( 3 ): 58 - 66, 80 .

王吉 , 刘子琦 , 等 . 蛇形微通道内绝热和沸腾流动气液两相压降的实验研究 [J ] . 制冷学报 , 2024 , 45 ( 04 ): 139 - 149 .

WANG Ji , LIU Ziqi , et al . Experimental study on gas-liquid pressure drop of adiabatic and boiling flow in serpentine microchannels [J ] . Journal of Refrigeration , 2024pr 45 ( 04 ): 139 - 149 .

朱天意 , 黄理浩 , 等 . R513A在水平管内流动沸腾传热特性的研究 [J ] . 制冷学报 , 2024 , 45 ( 05 ): 137 - 144 .

ZHU Tianyi , HUANG Lihao , et al . Study on flow boiling heat transfer characteristics of R513A in horizontal tube [J ] . Journal of Refrigeration , 2024pr 45 ( 05 ): 137 - 144 .

MIN Haitao , XIAO Jiawei , et al . Numerical investigation and structural optimization of a battery thermal management system based on refrigerant evaporation [J ] . Journal of Energy Storage , Volume 104, Part A, 2024 , 114438, ISSN 2352 - 152 X.

姚薇 . 基于直冷及相变材料散热的电池组热管理系统研究 [D ] . 浙江大学 , 2022 .

DOI:10.27461.( YAO Wei . Research on battery pack thermal management system based on direct cooling and phase change material heat dissipation [D ] . Zhejiang University 2022 . DOI: 10.27461 http://dx.doi.org/10.27461 )

Views

3326

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of Refrigerant Phase Transition on the Temperature Control of Large Capacity Lithium-ion Battery

Dynamic Modeling and Model Predictive Control Study of Direct Cooling Thermal Management System for Batteries

Experimental Study on Direct Refrigerant Battery Cooling System for Electric Vehicle

Influence of Refrigerant Phase Change on Temperature Control Performance of Direct Cooling System for Power Batteries

Optimal Investigation on the Thermal Management of Battery Based on a Bionic Shark Scale Structure

Related Author

Chen Qinghua

Wu Ruilong

Ji Jiadong

Shu Fan

Wang Jiafeng

Xu Xiangguo

高帅

王俊博

Related Institution

Institute of Energy, Hefei Comprehensive National Science Center

Ningbo Science and Innovation Center, Zhejiang University

Institute of Refrigeration and Cryogenics, Key Laboratory of Refrigeration and Cryogenic Technology of Zhejiang Province, Zhejiang University

Center for Balance Architecture, Zhejiang University

中国计量大学计量测试工程学院

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰

AI伴读

1,21,2<p>Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery<br></p>

DOI：

摘要

Abstract

关键词

Keywords

references

^1,2^1,2<p>Analysis of TheInfluence of Refrigerant Phase Transition on The Temperature Control of LargeCapacity Lithium-ion Battery<br></p>