Evaporation Performance Research of New Micro-fin Copper Tube

doi:10.3969/j.issn.0253-4339.2007.04.010

您当前的位置：

首页 >

文章列表页 >

Evaporation Performance Research of New Micro-fin Copper Tube

更新时间：2025-09-03

- Evaporation Performance Research of New Micro-fin Copper Tube
- Journal of Refrigeration Vol. 28, Issue 4, Pages: 54-58(2007)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2007.04.010
  CLC：
- Published：2007
- 稿件说明：
移动端阅览
Evaporation Performance Research of New Micro-fin Copper Tube[J]. Journal of Refrigeration, 2007, 28(4): 54-58.
DOI：

Evaporation Performance Research of New Micro-fin Copper Tube[J]. Journal of Refrigeration, 2007, 28(4): 54-58. DOI： 10.3969/j.issn.0253-4339.2007.04.010.

摘要

针对开发的瘦齿、交叉齿、光管及普通齿型内螺纹传热管单管蒸发传热实验数据进行了对比，相同工况下，各传热管管内换热系数均随着冷媒流量的增大而增大，交叉齿管换热系数比瘦齿管高出10％，瘦齿管换热系数高出普通齿管10％左右。四种齿型中，交叉齿管管内压降最大，光管其次，瘦齿管比普通齿管略有增加。相同结构尺寸，相同工况下，利用稳态分布参数模型，对以上四种内螺纹传热管蒸发器传热和流动性能进行了数值模拟分析比较。结果表明，交叉齿管蒸发器换热量最大，瘦齿管稍差，普通齿管其次，但均好于光管。整个流量变化范围内，4种蒸发器压降变化都相差不大，光管蒸发器压降变化较其它管型略有增加。研究结果对内螺纹传热管的开发和研究具有指导意义。

Abstract

The evaporation heat transfer was experimentally investigated for the slim

cross

smooth and general micro - fin tubes in our study. The results show that the heat transfer coefficients increase with the refrigerant mass flow rate for all tested tubes. The heat transfer coefficient of the cross micro-fin tube is 10% higher than that of the slim micro - fin tube

and again the latter is 10% higher than that of the general micro - fin tube. The pressure drop of the cross micro- fin tube is higher than that of the other micro - fin tubes. Based on the steady state distributed parameter model and the same configuration and test conditions

the performance of evaporators using the these four micro-fin tubes were calculated and compared with each other. The results indicate that the performance of the cross micro - fin tube evaporator is superior to the other evaporators. The pressure drop for the four evaporators is almost identical with a slightly higher pressure drop for the smooth tube evaporator.

关键词

Keywords

references

Views

508

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Analysis of Influencing Factors on Soil Thermal Conductivity Test in Ground Source Heat Pump

Numerical Simulation of Ice Slurry Flow in a Vertical Pipe

Numerical Simulation and Experimental Investigation of a Vapor Chamber

Numerical Simulation on Frost of Cryogenic Finned-Tube Vaporizer Based on Fractal Theory

3D Numerical Geometric Optimization of Plate Fin Heat Sinks in Natural Convection Heat Transfer

Related Author

Wang Fenghao

Yan Liang

Feng Chenchen

Wang Xinke

Wang Jihong

Zhang Tengfei

Wang Shugang

Liang Yuntao

Related Institution

Building Energy Research Center, Xi'an Jiaotong University

Shanghai Architectural Design & Research Institute Co., Ltd.

School of Civil Engineering, Dalian University of Technology

State Key Laboratory of Coal Safety Technology, Shenyang Branch of China Coal Research Institute

Graduate University of Chinese Academy of Science

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰

AI伴读