A Review of Studies on Corrosion and Protection of Finned Tube Heat Exchanger for Air Conditioner

Yu Xinquan; Sheng Jian; Zhang Hua; Yang Qiguo; Duan Yang

doi:10.3969/j.issn.0253-4339.2022.01.001

您当前的位置：

首页 >

文章列表页 >

A Review of Studies on Corrosion and Protection of Finned Tube Heat Exchanger for Air Conditioner

更新时间：2024-07-18

- A Review of Studies on Corrosion and Protection of Finned Tube Heat Exchanger for Air Conditioner
- Journal of Refrigeration Vol. 43, Issue 1, (2022)
- 作者机构：
  
  上海理工大学能源与动力工程学院
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2022.01.001
  CLC：
- Published：2022
- 稿件说明：
移动端阅览
Yu Xinquan, Sheng Jian, Zhang Hua, et al. A Review of Studies on Corrosion and Protection of Finned Tube Heat Exchanger for Air Conditioner[J]. Journal of refrigeration, 2022, 43(1).
DOI：

Yu Xinquan, Sheng Jian, Zhang Hua, et al. A Review of Studies on Corrosion and Protection of Finned Tube Heat Exchanger for Air Conditioner[J]. Journal of refrigeration, 2022, 43(1). DOI： 10.3969/j.issn.0253-4339.2022.01.001.

摘要

空调用翅片管式换热器长期使用会受到一定程度的腐蚀，影响换热器的换热性能，导致整个空调系统的能效降低。本文介绍了翅片管式换热器3种主要的腐蚀机理：蚁巢腐蚀、点蚀和间隙腐蚀，从形貌、压降及传热特性3个方面分析了腐蚀对翅片管式换热器性能的影响，结果表明：翅片管式换热器腐蚀后，传热系数和换热量均减小，空气侧压降受影响较小，在5 Pa以内。总结归纳了翅片管式换热器抗腐蚀性的研究现状，发现改善换热器抗腐蚀性能的研究集中于制备出耐腐蚀性更好的防腐涂层。最后，总结和展望了制冷空调换热器腐蚀防护的研究方向。

Abstract

The finned tube heat exchanger used in air conditioners becomes corroded after long-term use. This affects the heat exchange performance of the heat exchanger and reduces the energy efficiency of the entire air conditioning system. In this review

three main corrosion mechanisms of finned tube heat exchangers were introduced: ant-nest corrosion

pitting corrosion

and gap corrosion. The influence of corrosion on the performance of the finned tube heat exchanger was analyzed from three aspects: morphology

pressure drop

and heat transfer characteristics. The results show that the heat transfer coefficient and heat transfer of the finned tube heat exchanger decreased after corrosion. The air-side pressure drop was less affected (< 5 Pa). The research status of corrosion resistance of finned tube heat exchangers is summarized. It was found that research on improving the corrosion resistance of heat exchangers focused on the preparation of better corrosion-resistant coatings. Finally

future research directions for corrosion protection of refrigeration and air conditioning heat exchangers are summarized and discussed.

关键词

Keywords

references

Views

3047

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Research Progress of Microchannel Heat Sink Structures Based on Single-Phase Flow

Experimental Study on Flow Boiling Heat Transfer Characteristics of R513A Inside Horizontal Tubes

Experimental Study on the Performance of NH_3/CO_2 Cascade Heat Exchanger

Experimental Study on Resistance and Heat Transfer Characteristics of Plate Evaporative Air Cooler

Related Author

Zhao Jie

Cui Xiaoyu

Zhu Tianyi

Huang Lihao

Tao Leren

公绪金

王君竹

董玉奇

Related Institution

School of Energy and Power Engineering, University of Shanghai for Science and Technology

Shanghai Key Laboratory of Multiphase Flow and Heat Transfer in Power Engineering

哈尔滨商业大学能源与建筑工程学院

HVAC and Gas Institute, Tongji University

School of Mechanical Engineering, Tianjin Polytechnic University

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰