Study on Boiling Heat Transfer Characteristics of R290 in Horizontal Micro-tubes

Wang Haoyu; Liu Jianhua; Zhang Liang; Yu Xiaoxiao

doi:10.3969/j.issn.0253-4339.2020.03.078

您当前的位置：

首页 >

文章列表页 >

Study on Boiling Heat Transfer Characteristics of R290 in Horizontal Micro-tubes

更新时间：2024-07-18

- Study on Boiling Heat Transfer Characteristics of R290 in Horizontal Micro-tubes
- Journal of Refrigeration Vol. 41, Issue 3, (2020)
- 作者机构：
  
  上海理工大学能源与动力工程学院
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2020.03.078
  CLC：
- Published：01 January 2020
- 稿件说明：
移动端阅览
Wang Haoyu, Liu Jianhua, Zhang Liang, et al. Study on Boiling Heat Transfer Characteristics of R290 in Horizontal Micro-tubes[J]. Journal of refrigeration, 2020, 41(3).
DOI：

Wang Haoyu, Liu Jianhua, Zhang Liang, et al. Study on Boiling Heat Transfer Characteristics of R290 in Horizontal Micro-tubes[J]. Journal of refrigeration, 2020, 41(3). DOI： 10.3969/j.issn.0253-4339.2020.03.078.

摘要

本文研究了R290在内径为1 mm、2 mm和4 mm水平微细圆管内的沸腾流动换热特性，在饱和温度为15 ℃条件下，质量流速为50-600 kg/(m2?s)、干度为0~1、热流密度为5~20 kW/m2时对沸腾传热系数的影响进行了分析。通过实验发现，增大质量流速对传热系数具有增强作用，且在低干度区域质量流速对传热系数的影响较高干度区域小。在热流密度方面，传热系数随着热流密度的增大而增大，且在1 mm和2 mm 管内观察到了临界干度对传热系数的影响，这时传热系数有断崖式下降的趋势。在管径对于传热系数的影响方面，通过对不同管径换热特性的横向对比，在一定工况下传热系数随着管径的减小有所上升。本文还对R290已有的部分关联式进行了适配性验证。

Abstract

In this study the boiling heat transfer characteristics of R290 in a 1

and 4 mm horizontal micro-tube were investigated experimentally. The effects of mass flow rate [50-600 kg/(m2?s)]

quality (0-1)

and heat flux (5-20 kW/m2) on the boiling heat transfer coefficient at a saturation temperature of 15 °C were analyzed. The results showed that increased mass flow velocity can enhance the heat transfer coefficient and the influence of mass flow rate on the heat transfer coefficient with low quality is smaller than that with high quality. The heat transfer coefficient increased with the increased heat flux

and the effect of critical quality on the heat transfer coefficient was apparent in 2 and 1 mm tubes. The heat transfer coefficient tended to decrease precipitously for 2 and 1 mm tubes. The transverse heat transfer coefficient increased with the decreasing pipe diameter under some conditions. In addition

this study also verified the adaptability of some existing correlations of R290.

关键词

Keywords

references

Views

2220

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Comparative Study on the Performance of R404A Commercial Refrigerator Retrofitted with R290 and R454C

Comparison and Prospect of Alternative Refrigerants for MAC Based on New PFASs Restriction Regulation Proposal

Cooling and Heating Performance of an R290 Heat Pump System for Electric Cars

Experimental investigation on flow boiling heat transfer of R1233zd(E) in a variable width parallel microchannel

Simulation analysis and experimental study on R290 substituting for R134a electric vehicle compressor

Related Author

Su Minghong

Zhang Hua

Tian Yafen

Li Mengjia

Xue Wen

Wang Zebin

Ren Zhaolong

Cao Feng

Related Institution

Shanghai KINGDOM Refrigeration Equipment Co., Ltd.

School of Energy and Power Engineering, University of Shanghai for Science and Technology

School of Energy and Power Engineering, Xi′an Jiaotong University

Technical Institute of Physics and Chemistry, CAS

University of Chinese Academy of Sciences

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰