Study on Condensation Heat Transfer Performance of Natural Convection outside a Drop Tube Containing

Li Huijun; Jia Yiqiong

doi:10.3969/j.issn.0253-4339.2019.01.042

您当前的位置：

首页 >

文章列表页 >

Study on Condensation Heat Transfer Performance of Natural Convection outside a Drop Tube Containing

更新时间：2024-07-18

- Study on Condensation Heat Transfer Performance of Natural Convection outside a Drop Tube Containing
- Journal of Refrigeration Vol. 40, Issue 1, (2019)
- 作者机构：
  
  华北电力大学能源动力与机械工程学院
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2019.01.042
  CLC：
- Published：2019
- 稿件说明：
移动端阅览
Li Huijun, Jia Yiqiong. Study on Condensation Heat Transfer Performance of Natural Convection outside a Drop Tube Containing[J]. Journal of refrigeration, 2019, 40(1).
DOI：

Li Huijun, Jia Yiqiong. Study on Condensation Heat Transfer Performance of Natural Convection outside a Drop Tube Containing[J]. Journal of refrigeration, 2019, 40(1). DOI： 10.3969/j.issn.0253-4339.2019.01.042.

摘要

本文在自然对流情况下，基于双膜理论和边界层理论，考虑气液界面热阻，建立了滴形管外气液膜厚度及传热系数的数学模型，得到不同初始参数下气、液膜厚度，气、液膜热阻，气液界面热阻、凝液量和传热系数沿管壁的分布规律。结果表明：其他条件不变，随着混合气压力的增大(由81325Pa增加至121325Pa时)，液膜厚度增大(约7%)，传热系数减小(约30%)。随着不凝气体质量含量的增加(由0.1%增加至10%时)，虽然气膜厚度减小(约52%)，但气膜内不凝气体的质量含量增加(约58%)，气膜传热阻力增大(约61%)。对于当量直径相同的滴形管，其他条件不变，滴形管下半部分曲率越大，越易发生液膜分离，传热系数越大。

Abstract

Based on the double-film and boundary-layer theories

a mathematical model of the gas- and liquid-film thicknesses and the heat transfer coefficient of a drop tube were established

which considers the vapor-liquid interfacial thermal resistance. The distributions of the gas- and liquid-film thicknesses and heat transfer coefficient along the tube wall under different initial parameters and curvatures were obtained by simulation. The results indicate that the heat transfer coefficient is decreased (by approximately 30%) and the liquid-film thickness is increased (by approximately 7%) with the increase in the mixing gas pressure (when the pressure is from 81 325 to 121 325 Pa). With the increase in the non-condensable gas mass content (when the non-condensable gas-mass content is from 0.1% to 10%)

the film thickness is decreased (by approximately 52%)

the mass content of the non-condensable gas in the gas film is increased (by approximately 58%)

and the heat transfer resistance of the gas film is increased (by approximately 61%). For an equivalent drop-tube diameter with the other conditions remaining unchanged

the larger the curvature is

the easier the separation of the liquid film is

and the larger the heat transfer coefficient is.

关键词

Keywords

references

Views

2424

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental Investigation on the Flow and Heat Transfer Characteristics of a Fin and Tube Heat Exchanger Used in Battery Thermal Management

Review on Dryout of CO2 During Flow Boiling Heat Transfer

Study on Forming Mechanism of Condensate Film of Steam-gas Mixed Fluid

Heat Transfer Characteristics of Refrigerant-oil Mixture Flow Boiling inside Circular Tubes Filled with Metal Foam

Experimental Investigation on Two-phase Flow Pressure Drop of R22 during Condensation in a Rectangular Microchannel

Related Author

JI Wen-Tao

MA Ke-Shuai

WAN Hong-Niu

DU Yi

LIU Yi

Liu Jianhua

Zhang Liang

Ge Qilin

Related Institution

Qingdao Qiushi Industrial Technology Research Institute

Key Laboratory of Thermo-Fluid Science and Engineering of MOE, School of Energy and Power Engineering, Xi’an Jiaotong University

School of Energy and Power Engineering, University of Shanghai for Science and Technology

Department of Power Engineering, School of Energy Power and Mechanical Engineering, North China Electric Power University

Institute of Refrigeration and Cryogenics, Shanghai Jiao Tong University

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰