Experimental Investigation on the Distribution Performance of Refrigerant Distributors

Han Qing; Zhang Chi; Xu Bo; Chen Jiangping

doi:10.3969/j.issn.0253-4339.2014.03.001

您当前的位置：

首页 >

文章列表页 >

Experimental Investigation on the Distribution Performance of Refrigerant Distributors

更新时间：2024-07-18

- Experimental Investigation on the Distribution Performance of Refrigerant Distributors
- Journal of Refrigeration Vol. 35, Issue 3, (2014)
- 作者机构：
  
  上海交通大学制冷与低温工程研究所
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2014.03.001
  CLC：
- Published：2014
- 稿件说明：
移动端阅览
Han Qing, Zhang Chi, Xu Bo, et al. Experimental Investigation on the Distribution Performance of Refrigerant Distributors[J]. Journal of refrigeration, 2014, 35(3).
DOI：

Han Qing, Zhang Chi, Xu Bo, et al. Experimental Investigation on the Distribution Performance of Refrigerant Distributors[J]. Journal of refrigeration, 2014, 35(3). DOI： 10.3969/j.issn.0253-4339.2014.03.001.

摘要

分液器是制冷系统中重要的辅助设备，分液不均会引起换热器面积不能充分利用，制冷能力下降，蒸发器出风温度不均，膨胀阀阀芯振动等问题，合理选择和设计分液器对制冷系统高效运行有着重要的意义。文中介绍了压降式、离心式和贮液式三种分液器的工作原理，并且通过实验定量地研究了质量流量50~110 kg/h，入口干度0.1~0.3工作条件下，质量流量和入口干度对三种分液器分配特性的影响，引入各支路间质量和干度的标准偏差STDm和STDx评估分液均匀性。实验结果表明，当质量流量从50 kg/h增大到110 kg/h时，三种分液器的STDm减小，质量流量的均匀性得到改善。其中对压降型和离心式的影响较大，STDm分别降低了77%和51%，而对贮液型的影响较小，STDm降低了21%。当入口干度增大时，分液均匀性有所下降。

Abstract

Refrigeration mal-distribution in a distributor located at the inlet of a heater exchanger plays an important role in the heat exchanger performance. This paper proposes a test method to measure the mass flow rate and quality of each branch tube after distributor. Three types of distributors (pressure drop; centrifugal and reservoir) were manufactured and tested. It was found that with the increase of mass flow rate

the performance of distributor improved. The pressure drop and centrifugal type is more sensitive than reservoir one. With the increase of inlet quality

the performance of distribution deteriorates. The flow behavior of two-phase refrigerant such as phase distribution and separation phenomena was studied by CFD

which helped investigate how the geometry factors influence the distribution performance.

关键词

Keywords

references

Views

2068

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

The CFD Application in the Design of the Rotary Compressor

Numerical Analysis on the Flow Noise in the Indoor Unit and Cross Flow Fan of Air-conditioners

Related Author

Chen Zhenming

Xie Lichang

Shao Shuangquan

Lu Dawei

Jeon Won-Ho

Related Institution

Zhuhai Landa Compressor Co., Ltd.

Technical Institute of Physics and Chemistry, CAS

Chengde Special Equipment Supervision & Testing Center

CEDIC Co.,Ltd.

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰