Theoretical Limit of Chiller Efficiency

Zhou Jinsheng

doi:10.3969/j.issn.0253-4339.2013.01.069

您当前的位置：

首页 >

文章列表页 >

Theoretical Limit of Chiller Efficiency

更新时间：2024-07-18

- Theoretical Limit of Chiller Efficiency
- Journal of Refrigeration Vol. 34, Issue 1, (2013)
- 作者机构：
  
  英格索兰亚太工程技术中心
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2013.01.069
  CLC：
- Published：2013
- 稿件说明：
移动端阅览
Zhou Jinsheng. Theoretical Limit of Chiller Efficiency[J]. Journal of refrigeration, 2013, 34(1).
DOI：

Zhou Jinsheng. Theoretical Limit of Chiller Efficiency[J]. Journal of refrigeration, 2013, 34(1). DOI： 10.3969/j.issn.0253-4339.2013.01.069.

摘要

分析了冷水机组的换热器热平衡，推导了其制冷性能系数极限值的计算方法。在GB/T18430.1—2007及AHRI 550/590—2011规定的工况下，分别对水冷冷水机组及风冷冷水机组的制冷性能系数COP的极限值及综合部分负荷性能系数IPLV的极限值进行了计算。结果表明，水冷冷水机组在GB/T18430.1—2007下的满负荷COP的极限值为10.01，IPLV的极限值为14.51，在AHRI 550/590—2011下的相应值分别为10.07及17.30。风冷冷水机组的相应值分别为7.37/10.25及7.30/16.11。风冷冷水机组盘管换热面积的大小及效率的高低会直接影响空气的温升大小，进而决定冷凝温度的高低，如果不能通过改进盘管设计、增大换热面积、提高盘管换热效率的方法，使满负荷下的盘管空气温升低于10℃，风冷冷水机组满负荷COP的极限值只有7.37，IPLV不可能超过10.25。

Abstract

The energy conservation in chiller exchangers are analyzed in this paper

the formula of limit of coefficient of performance (COP) is then deduced. According to the working condition of GB/T 18430.1—2007 and AHRI 550/590—2011

the limits of COP and IPLV are calculated for water cooled chiller and air cooled chiller respectively. The results show that

the COP limit and IPLV limit of water cooled chiller is 10.01/14.51 at GB/T 18430.1—2007 condition and 10.07/17.3 at AHRI 550/590—2011 condition. For air cooled chiller

those values are 7.37/10.25 and 7.30/16.11. The air temperature increase through condenser coil and the condensing temperature is decided by its heat transfer area and effectiveness. If the former temperature in full load at rated condition can’t be achieved to be less than 10℃ by means of improving coil configuration

enlarging heat transfer area and improving the heat transfer effectiveness

the limit of COP of air cooled chiller in full load will be no more than 7.37

IPLV can’t be higher than 10.25.

关键词

Keywords

references

Views

3426

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental Investigation on Water Fouling Risk in Small Diameter Tubes of Chillers

Experimental Research on Design and Operation Characteristics of Large Temperature Difference Centrifugal Chiller

Research on Fault Diagnosis of Chillers Based on Improved BP Network

Research on COP Prediction Model of Chiller Based on PSO-SVR

Related Author

Zhang Huan

Ma Chao

Shao Yanpo

Li Ning

Li Feng

Yue Bao

Luo Mingwen

Ding Guoliang

Related Institution

GD Midea Refrigeration Equipment Co., Ltd.

GD Midea HVAC Equipment Co., Ltd.

Institute of Refrigeration and Cryogenic Engineering, Shanghai Jiao Tong University

State Key Laboratory of Air-conditioning Equipment and System Energy Conservation

浙江大学电气工程学院

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰