Study on Low Temperature Applications of R404A for Semi-hermetic Reciprocating Refrigeration Compressor

Qin Haijie; Yu Shitao; Liu Jinglin

doi:10.3969/j.issn.0253-4339.2007.04.004

您当前的位置：

首页 >

文章列表页 >

Study on Low Temperature Applications of R404A for Semi-hermetic Reciprocating Refrigeration Compressor

更新时间：2025-09-03

- Study on Low Temperature Applications of R404A for Semi-hermetic Reciprocating Refrigeration Compressor
- Journal of Refrigeration Vol. 28, Issue 4, Pages: 26-32(2007)
- 作者机构：
  
  大连三洋压缩机有限公司,大连,116033
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0253-4339.2007.04.004
  CLC：
- Published：2007
- 稿件说明：
移动端阅览
Qin Haijie, Yu Shitao, Liu Jinglin. Study on Low Temperature Applications of R404A for Semi-hermetic Reciprocating Refrigeration Compressor[J]. Journal of Refrigeration, 2007, 28(4): 26-32.
DOI：

Qin Haijie, Yu Shitao, Liu Jinglin. Study on Low Temperature Applications of R404A for Semi-hermetic Reciprocating Refrigeration Compressor[J]. Journal of Refrigeration, 2007, 28(4): 26-32. DOI： 10.3969/j.issn.0253-4339.2007.04.004.

摘要

通过对大连三洋压缩机有限公司生产的半封闭活塞式制冷压缩机C—L150M82，分别应用R404A与R22在低温工况下的对比实验研究，来分析使用环保型制冷剂R404A替换R22的可行性。实验研究表明：第一，半封闭活塞式制冷压缩机在保持配置不变的条件下，在低温工况下，保持冷凝温度不变，使用R404A比使用R22制冷量有明显提升，随着蒸发温度的降低制冷量可提升10％～30％；第二，在冷凝温度不变条件下，使用R404A可以达到-45℃蒸发温度；第三，使用R404A后压缩机排气温度比R22有明显降低；第四，过冷过热循环对R404A系统都有明显的性能改善。

Abstract

Experiments on a reciprocating compressor C- L150M82 using R404A and R22 were conducted under low temperature working conditions. The feasibility of replacing R22 with R404A was analyzed based on the experimental data. The results show that with the same configuration and under the low temperature working condition

the refrigerating capacity of the compressor with R404A is greatly higher than that with R22

if the condensing temperature does not change. With the falling of evaporating temperature

the capacity can rise by 10% - 30%. Moreover

at the same condensing temperature

the evaporating temperature for the compressor using R404A can reach - 45%. Furthermore

the discharge temperature of the compressor using R404A is lower than that using R22 significantly. In addition

the application of both superheat and subcool recycles can improve the performance of R404A refrigeration system.

关键词

Keywords

references

Views

413

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Development of integrative multi-loop control experiment system for refrigeration and air-conditioning

Experimental Study on Air Conditioning System with Heat Recovery of Compressor Discharge Gas

Experimental Research on Electronic Expansion Valve Refrigerant Flow Coefficient

Experimental Study on Close Loop Self-oscillating Heat Pipe: A State-of-the-art Review

Experimental research of water-to-water heat pump driven by naturalgas-engine

Related Author

杨昭

张世钢

程珩

谢英柏

吴志光

马虎根

蔡祖恢

陈剑波

Related Institution

天津大学热能研究所天津300072 (杨昭，张世钢，程珩)，天津大学热能研究所天津300072(谢英柏

[1]天津大学热能研究所天津300072 [2]上海理工大学动力工程学院上海

[1]上海理工大学城建学院上海200093 [2]江苏萃隆铜业有限公司江苏常熟

[1]上海交通大学机械与动力工程学院,上海200030 [2]青岛海信空调有限公司

浙江大学制冷与低温研究所杭州310027 (王葳，张绍志，陈光明)，浙江大学制冷与低温研究所杭州310027(尤鹏青

Address：10/F, Yindu Mansion, 67 Fucheng Road, Haidian Dist, Beijing, China Postal code：100142
Tel：010-68711412 Email：editor@car.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09064830号-19 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰